ART
BEAUTY & WELLNESS
CRAFT
CULTURE & HISTORY
ENTERTAINMENT
ENVIRONMENT
FOOD & DRINKS
REVERSE ENGINEERING
SCIENCES
SPORTS
TECHNOLOGY
WEARABLES

Bore and Tone Holes: A Hole Can Be Made Bigger and Not Smaller
A wind instrument is a column of air with a length. Change the length and the note changes, and the whole craft is about changing it in controlled steps.
Two facts decide almost everything. A pipe closed at one end sounds an octave lower than an open one of the same length, which is why panpipes are surprisingly short. And a tone hole does not end the air column at the hole — it ends it somewhere below, by an amount that depends on how big the hole is.
That second fact is the working rule of the whole craft: cut every hole small and tune it by enlarging it, because wood cannot be put back.
Intermediate
5 hours
Instructions
1
1
Open, closed, and how the instrument is excited
Open, closed, and how the instrument is excited
**An open pipe** — a flute, a recorder, a quena — resonates at a half wavelength and overblows to the octave, then the twelfth, giving the full harmonic series.
**A pipe closed at one end** — a panpipe, a stopped organ pipe, a clarinet — resonates at a quarter wavelength. It sounds an octave lower for the same length and it produces only the odd harmonics, so it overblows to the twelfth and skips the octave entirely. That is why a clarinet's fingering changes so awkwardly between registers, and why its lowest note is so low for its size.
How the column is set going is a separate question from its length:
**An air jet across an edge** — flute, quena, shakuhachi, panpipes, and the fipple of a recorder or whistle. The jet flaps in and out of the pipe at the resonance.
**A beating reed** — clarinet, oboe, bagpipe chanter. A tongue of cane opens and closes the entrance, and it acts as a closed end.
**A free reed** — sheng, khaen, accordion, harmonica. The tongue swings through a slot and its own stiffness sets the pitch, so the pipe is a resonator rather than the thing that decides the note.
Materials for this step:
Bamboo3 piecesTools needed:
Steel Ruler
Chromatic Tuner and Metronome (Clip-On)2
2
Lengths, corrections and hole positions
Lengths, corrections and hole positions
Loading Jupyter Notebook...
Tools needed:
Desktop Computer3
3
Cutting and tuning a simple flute
Cutting and tuning a simple flute
Work in this order and nothing is wasted.
**Cut the tube long.** Longer than the calculation, by 20 mm or more. The overall length is the one dimension that can be corrected by cutting, and only in one direction.
**Make the embouchure or fipple first and tune the whole tube.** With no finger holes at all, the pipe sounds one note. Shorten it until that note is right. Now the length is known to be correct before a single hole is drilled.
**Mark the holes from the calculation, then drill them undersized.** Two millimetres under is a reasonable start.
**Tune from the bottom hole upwards**, enlarging each until it is in tune, because each hole's pitch depends on the ones below it being open.
**Undercut rather than enlarge, when the hole is already as big as a finger can seal.** Angling the walls of the hole inside the bore raises the pitch further while the opening the finger covers stays the same size. That is the traditional fix for a hole that has run out of room.
Check the tuning warm and with the pipe wet. Both change the pitch, and the instrument is played in that state, not cold and dry.
Materials for this step:
Bamboo2 pieces
Beeswax1 pieceTools needed:
Drill Bit Set
Needle File Set
Digital Caliper 6-Inch
Chromatic Tuner and Metronome (Clip-On)
Fine Sandpaper4
4
The bore is not just a hole through the middle
The bore is not just a hole through the middle
A cylinder is the simplest bore and not the only one, and the shape changes which harmonics line up.
**Cylindrical** — flute, clarinet, most bamboo flutes. Simple to make, and the harmonic behaviour follows the open or closed rule directly.
**Conical, widening towards the bell** — oboe, bassoon, saxophone, many folk shawms. A cone driven by a reed at its narrow end behaves like an OPEN pipe: it overblows to the octave and gives all the harmonics, although the reed closes one end. That is why a saxophone overblows an octave and a clarinet a twelfth, although both are single-reed instruments.
**Bore diameter changes the tone more than the pitch.** A wider bore for a given length is louder, darker, harder to overblow; a narrow bore is quieter, brighter and jumps to the upper registers easily. The shakuhachi's wide bore and the quena's narrow one are two deliberate answers.
**Small irregularities matter.** A ridge, a node left in a bamboo tube, or a rough patch sits somewhere in a standing wave, and its effect depends on where. Near a pressure maximum it changes the note; near a node it does almost nothing. This is why traditional makers ream and polish a bore, and why two tubes of identical length do not always play the same.
Materials for this step:
Bamboo3 piecesTools needed:
Digital Caliper 6-Inch
Rasp
Fine Sandpaper
Chromatic Tuner and Metronome (Clip-On)Related Blueprints
These blueprints share knowledge with this one — techniques, materials, or principles that connect them in the learning graph.
CC0 Public Domain
This blueprint is released under CC0. You are free to copy, modify, distribute, and use this work for any purpose, without asking permission.
Support the Maker by purchasing products through their Blueprint where they earn a Maker Commission set by Vendors, or create a new iteration of this Blueprint and include it as a connection in your own Blueprint to share revenue.


