ART
BEAUTY & WELLNESS
CRAFT
CULTURE & HISTORY
ENTERTAINMENT
ENVIRONMENT
FOOD & DRINKS
REVERSE ENGINEERING
SCIENCES
SPORTS
TECHNOLOGY
WEARABLES
The Clapboard Gauge: One Man, Straight Siding, Even in the Wind
Woody

Created by

Woody

30. September 2026NO
20
0
0
0
0

The Clapboard Gauge: One Man, Straight Siding, Even in the Wind

Siding put on with compasses and set-nails takes two men, mars the boards with nail holes, and lets each course drift a little from the last. Stephen Inman of Rockford, Illinois, received US 33,199, dated 3 September 1861, for a combined siding hook and gauge "so arranged as to combine in one and to answer the purpose of a square, siding-hook, chalk-line, compasses, and set-nails used in siding up buildings". Its lip catches under the course already nailed, a cross-piece squares it to the board, an adjustable slider sets the exposure, and springs hold the next board in place, so "only one is required, for the springs N keep the siding in place." This rung works out how much straighter a gauge keeps the courses, then builds two gauges from hardwood and lays strips on a mock wall.
Intermediate
About 4 hours

Instructions

1

Course error, measured against gauged

Loading Jupyter Notebook...
2

Square to the board

The embedded blueprint trues a try square. Inman's cross-piece does the square's job on the wall, bringing the gauge at right angles to the siding.
3

Read US 33,199

"In Fig. 1, E is a shank, to the upper part of which is secured the wedge or lip F, that is forced up between two pieces of siding to hold the hook in place. On the outside of this shank is secured by means of the thumb-screw J the slider or standard H, that forms a rest K on the top and terminates in the piece L, to which is jointed the gage M." "In the way siding is usually put on, compasses have to be used to measure the distance and then set-nails driven in, which consumes much time and mars the siding with the holes after the nails are withdrawn, and does not insure as much accuracy of measurement as where two or more of these hooks are used, if they are adjusted and placed in the siding just alike."
4

Build two gauges and side a mock wall

**Shank and lip.** For each gauge, saw a shank 30 × 3 cm from hardwood board and glue a thin wedge-shaped lip across its top face to slip up under the bottom edge of a board. Screw a cross-piece across the shank just below the lip so it bears against the face of the course below and squares the gauge. **Slider.** Saw a slider 12 × 3 cm, cut a slot 6 cm long down it with the coping saw, and hold it on the shank with a bolt and nut through the slot, so it can be set to the exposure. Screw a block across its top as the rest the next board sits on. **Spring.** Screw a curved strip of spring steel to the slider so it presses the new board against the wall. **Test.** Screw a plywood sheet upright as the wall and cut strips 10 cm wide from pine board as siding. Nail the first strip level. Set both gauges to 7 cm exposure, hook them under it, rest the next strip on them, and nail it. Repeat for eight courses. Side a second sheet by marking each course with the ruler and pencil. Measure each course's exposure with the caliper on both walls and compare the spread.

Materials for this step:

Hardwood BoardHardwood Board1 piece
Plywood SheetPlywood Sheet1 piece
Pine BoardPine Board2 pieces
Spring Steel StripSpring Steel Strip1 piece
Hex Bolt AssortmentHex Bolt Assortment1 piece
Hex NutHex Nut2 pieces
Wood ScrewsWood Screws12 pieces
Wood GlueWood Glue5 ml
NailsNails40 pieces

Tools needed:

Hand SawHand Saw
Coping SawCoping Saw
Cordless DrillCordless Drill
Drill Bit SetDrill Bit Set
Screwdriver SetScrewdriver Set
Adjustable WrenchAdjustable Wrench
HammerHammer
Try SquareTry Square
RulerRuler
Digital Caliper 6-InchDigital Caliper 6-Inch
PencilPencil
5

Siding that runs out of level, slips or gaps

Clapboard gauge troubleshooting.

Flow

Loading...
6

History and honest limits

**Stephen Inman** of Rockford, Winnebago County, Illinois, received US 33,199, dated 3 September 1861. His slider was adjusted by ratchets and a hand-screw, the gauge was jointed so it could be lifted when a board had to be scribed round a window, and he did not claim the metal siding hook itself, only the cross-piece combined with the gauge. **Honest limits.** Hardwood, a slotted slider and a spring-steel strip stand in for his hook, ratchet slider and springs, and a plywood mock wall for a building. The notebook's per-course errors are examples, not measurements. Your caliper readings are the result.

Materials

9

Tools Required

11

CC0 Public Domain

This blueprint is released under CC0. You are free to copy, modify, distribute, and use this work for any purpose, without asking permission.

Support the Maker by purchasing products through their Blueprint where they earn a Maker Commission set by Vendors, or create a new iteration of this Blueprint and include it as a connection in your own Blueprint to share revenue.

Discussion

(0)

Log in to join the discussion

Loading comments...