SENI
KECANTIKAN & KESEHATAN
KERAJINAN
BUDAYA & SEJARAH
HIBURAN
LINGKUNGAN
MAKANAN & MINUMAN
REKAYASA BALIK
ILMU PENGETAHUAN
OLAHRAGA
TEKNOLOGI
PERANGKAT PAKAI
Ball Bearings: Races, Balls and Cage
Emma

Dibuat oleh

Emma

11. Oktober 2026SE
23
0
0
0
0

Ball Bearings: Races, Balls and Cage

A ball bearing has four parts: an outer race, an inner race, the balls that roll between them, and a cage that keeps the balls evenly spaced. Almost all of it is steel, usually 52100 (1.5% chromium, 1% carbon), which can be made very hard and tough by heat treating; 440C stainless is used where rust is a problem. The races are turned from tubing, the balls are cold headed from thick wire, both are hardened, tempered, ground and lapped to an almost mirror finish, and the cage is stamped from thin sheet. Even an inexpensive bearing's balls may be out of round by no more than 25 millionths of an inch; precision bearings allow five millionths.
Lanjutan
Factory process

Instruksi

1

Turn the races

Cut the basic shape of both races from steel tubing on automatic lathe-like machines, leaving every dimension slightly oversize: the steel usually warps in heat treatment.

Material untuk langkah ini:

Pipa baja bantalan (52100)Pipa baja bantalan (52100)1 as required

Alat yang dibutuhkan:

Mesin bubut otomatisMesin bubut otomatis
2

Harden and temper the races

Heat to about 843 °C (1,550 °F) for up to several hours depending on size, then quench in oil: hard but brittle. Temper at about 149 °C (300 °F) and let cool in air: hard and tough.

Alat yang dibutuhkan:

Tungku pengerasan kontinu dengan celup oliTungku pengerasan kontinu dengan celup oli
Oven temperOven temper
3

Grind and lap the races

The hardened steel is too hard to cut, so grind almost every surface: the fitting surfaces round, the sides flat. Grind the ball track, then lap it for several hours with a very fine abrasive slurry to an almost mirror finish.

Alat yang dibutuhkan:

Mesin gerinda cincin bantalanMesin gerinda cincin bantalan
Mesin lapping jalurMesin lapping jalur
Kompon lappingKompon lapping
4

Cold head the balls

Feed thick wire from a roll into a machine that cuts off a short piece and smashes both ends in toward the middle between two dies, without heating. The ball comes out with a ring of "flash" round its middle.

Material untuk langkah ini:

Kawat baja bantalan (52100)Kawat baja bantalan (52100)1 as required

Alat yang dibutuhkan:

Mesin tempa dingin kepalaMesin tempa dingin kepala
5

Remove the flash

Run the balls many times round rough grooves between two cast-iron discs, one turning and one fixed, until the flash is gone and they are nearly round. Leave about 0.008 in (0.2 mm) for finishing.

Alat yang dibutuhkan:

Mesin penghilang sirip bolaMesin penghilang sirip bola
6

Harden, grind and lap the balls

Heat treat and temper the balls like the races. Grind them in the same kind of disc machine with grinding wheels to within a few ten-thousandths of an inch, then lap them 8–10 hours on cast-iron wheels with lapping compound.

Alat yang dibutuhkan:

Tungku pengerasan kontinu dengan celup oliTungku pengerasan kontinu dengan celup oli
Oven temperOven temper
Mesin gerinda bolaMesin gerinda bola
Mesin lapping bolaMesin lapping bola
Kompon lappingKompon lapping
7

Stamp the cage

Stamp the cage halves from thin steel sheet and bend them to shape in a die. (Plastic cages are injection moulded instead.)

Material untuk langkah ini:

Lembaran bajaLembaran baja1 as required

Alat yang dibutuhkan:

Mesin tekan stampingMesin tekan stamping
8

Assemble

Put the inner race inside the outer race, pushed as far to one side as it goes, and drop the balls into the gap opposite. Centre the races and spread the balls evenly, fit the cage (steel cages riveted, plastic ones snapped in) and coat the bearing with a thin film of petroleum jelly against rust.

Material untuk langkah ini:

Paku keling bajaPaku keling baja1 as required
VaselinVaselin1 as required

Bahan

5

Alat yang Diperlukan

11

CC0 Domain Publik

Cetak biru ini dirilis di bawah CC0. Anda bebas untuk menyalin, memodifikasi, mendistribusikan, dan menggunakan karya ini untuk tujuan apa pun, termasuk komersial, tanpa meminta izin.

Dukung Maker dengan membeli produk melalui Cetak Biru mereka di mana mereka mendapatkan Komisi Pembuat yang ditetapkan oleh Penjual, atau buat iterasi baru dari Cetak Biru ini dan masukkan sebagai koneksi di milik Anda sendiri.

Diskusi

(0)

Masuk untuk bergabung dengan diskusi

Memuat komentar...