SENI
KECANTIKAN & KESEHATAN
KERAJINAN
BUDAYA & SEJARAH
HIBURAN
LINGKUNGAN
MAKANAN & MINUMAN
REKAYASA BALIK
ILMU PENGETAHUAN
OLAHRAGA
TEKNOLOGI
PERANGKAT PAKAI
Counterflow: The Same Area Does More When the Streams Run Opposite
Youblob (generated from this blueprint's notebook) · CC0
Emma

Dibuat oleh

Emma

27. September 2026SE
4
0
0
0
0

Counterflow: The Same Area Does More When the Streams Run Opposite

Every heat exchanger in this batch — the economiser, the condenser, the plate exchanger — is built to one rule: make the hot and cold streams run in opposite directions. It is the single cheapest improvement in heat transfer, because it costs no extra metal. Run the same way, two streams approach a common middle temperature and stop; the cold one can never leave hotter than the hot one does. Run opposite, the cold stream meets the hottest fluid just as it leaves, and can come out warmer than the hot stream exits. This rung builds a tube-in-tube exchanger from a copper tube inside a hose, logs four temperatures with an Arduino, and runs it both ways to measure the difference.
Menengah
About 5 hours

Instruksi

1

Parallel against counterflow, in numbers

Memuat notebook Jupyter…
2

Build a tube-in-tube exchanger

Take 2 m of 10 mm copper tube and slide it inside 2 m of clear vinyl tube with a bore comfortably larger — the annulus between them is the second channel. At each end fit a tee from the PVC fittings kit: the copper passes straight through the tee and is sealed where it exits with silicone; the tee's side branch is the jacket connection. You now have two independent channels: inside the copper, and between copper and vinyl. Coil the whole thing loosely and insulate it with glass wool, leaving the four connections free. Push a waterproof temperature probe into each of the four connections through a hole sealed with silicone.

Material untuk langkah ini:

Pipa tembaga 10 mmPipa tembaga 10 mm2 meter
Selang vinil beningSelang vinil bening2.5 meter
Aneka Sambungan Pipa PVCAneka Sambungan Pipa PVC1 set
Sealant SilikonSealant Silikon1 buah
Isolasi wol kacaIsolasi wol kaca1 sqm
Aneka klem selangAneka klem selang1 set
Temperature Sensor - Waterproof (DS18B20)Temperature Sensor - Waterproof (DS18B20)4 buah

Alat yang dibutuhkan:

Pemotong pipaPemotong pipa
Bor Tanpa KabelBor Tanpa Kabel
Set Mata BorSet Mata Bor
Sarung Tangan Kerja KulitSarung Tangan Kerja Kulit
3

The logger

Four DS18B20 probes on a single data wire, logging hot in, hot out, cold in and cold out every few seconds as comma-separated lines you can paste into the notebook or a spreadsheet.
hx_logger.inoarduino
/*
  hx_logger.ino -- log the four temperatures of a tube-in-tube heat exchanger.

  Four DS18B20 waterproof probes on ONE data wire: hot in, hot out, cold in,
  cold out. Libraries (Library Manager): "OneWire" and "DallasTemperature".
  Wiring: all probes' red -> 5V, black -> GND, yellow (data) -> D2.
          Pull-up between D2 and 5V of about 4.7 k: two 10 k resistors in
          parallel give 5 k, which works on short leads.
  First run prints each probe's address: label the probes in that order.
*/
#include <OneWire.h>
#include <DallasTemperature.h>

const int PIN_BUS = 2;
OneWire bus(PIN_BUS);
DallasTemperature sensors(&bus);
DeviceAddress addr[4];
const char* NAMES[4] = {"hot_in", "hot_out", "cold_in", "cold_out"};
int found = 0;

void printAddress(DeviceAddress a) {
  for (int i = 0; i < 8; i++) {
    if (a[i] < 16) Serial.print('0');
    Serial.print(a[i], HEX);
  }
}

void setup() {
  Serial.begin(9600);
  sensors.begin();
  found = sensors.getDeviceCount();
  if (found > 4) found = 4;
  for (int i = 0; i < found; i++) {
    sensors.getAddress(addr[i], i);
    sensors.setResolution(addr[i], 12);
    Serial.print(F("# probe ")); Serial.print(i); Serial.print(F(" = "));
    printAddress(addr[i]); Serial.print(F(" -> ")); Serial.println(NAMES[i]);
  }
  Serial.println(F("seconds,hot_in,hot_out,cold_in,cold_out"));
}

void loop() {
  sensors.requestTemperatures();          // ~750 ms at 12-bit resolution
  Serial.print(millis() / 1000);
  for (int i = 0; i < found; i++) {
    Serial.print(',');
    Serial.print(sensors.getTempC(addr[i]), 2);
  }
  Serial.println();
  delay(4000);
}

/*
  The heat each side carried, from the logged steady values:
     Q_hot  = m_hot  * 4186 * (hot_in  - hot_out)    watts, m in kg/s
     Q_cold = m_cold * 4186 * (cold_out - cold_in)
  They should agree within a few per cent. If Q_hot is much larger, heat is
  leaking out of the jacket to the room: insulate it.
*/

Material untuk langkah ini:

Arduino Uno R3Arduino Uno R31 buah
Resistor 10 kiloohmResistor 10 kiloohm2 buah
Kabel JumperKabel Jumper1 set

Alat yang dibutuhkan:

Komputer dengan Arduino IDEKomputer dengan Arduino IDE
4

Run it both ways

Feed the copper with hot water from a bucket on a shelf — about 60 °C from a kettle topped up with cold — and the jacket with cold tap water. Set both flows to the same rate by timing each outlet into a measuring jug (aim for about 1 litre per minute). **Parallel:** both streams enter at the same end. Let the logger settle for five minutes and note the four temperatures. **Counterflow:** swap the jacket's hoses so the cold enters at the far end. Keep both flows the same. Settle and note. Compare the cold outlet in the two runs. In counterflow it comes out noticeably warmer — often warmer than the hot outlet — with no change to the hardware except which way one hose points. Work out the heat each side carried; they should agree within a few per cent.

Material untuk langkah ini:

AirAir40 liter

Alat yang dibutuhkan:

Ceret listrik kacaCeret listrik kaca
EmberEmber
Kendi takarKendi takar
StopwatchStopwatch
Termometer dapurTermometer dapur
5

Context

A practice rung: no patent anchors counterflow — it is physics that engineers learned and wrote into every exchanger. The effectiveness–NTU method used in the notebook was set out in the mid-twentieth century and is how exchangers are sized today. Where it shows up in this catalogue: the economiser meets the coolest gas with the coldest water; the Stirling engine's regenerator and a rocket's regenerative cooling both depend on it; the Linde air liquefier works only because its counterflow exchanger lets the cold returning gas pre-cool the incoming gas. **Honest limits.** Counterflow gains most when you want the streams to approach each other's temperatures; for a small temperature change on one side it matters less. And it cannot beat the laws: with equal flows even a perfect counterflow exchanger only approaches 100 % effectiveness as its area goes to infinity.

Bahan

11

Alat yang Diperlukan

10
Estimasi total
Yang dibeli pembuatnya. Bahan tanpa harga didapat di tempat kamu membelinya.
$37.72

CC0 Domain Publik

Cetak biru ini dirilis di bawah CC0. Anda bebas untuk menyalin, memodifikasi, mendistribusikan, dan menggunakan karya ini untuk tujuan apa pun, termasuk komersial, tanpa meminta izin.

Dukung Maker dengan membeli produk melalui Cetak Biru mereka di mana mereka mendapatkan Komisi Pembuat yang ditetapkan oleh Penjual, atau buat iterasi baru dari Cetak Biru ini dan masukkan sebagai koneksi di milik Anda sendiri.

Diskusi

(0)

Masuk untuk bergabung dengan diskusi

Memuat komentar...