SENI
KECANTIKAN & KESEHATAN
KERAJINAN
BUDAYA & SEJARAH
HIBURAN
LINGKUNGAN
MAKANAN & MINUMAN
REKAYASA BALIK
ILMU PENGETAHUAN
OLAHRAGA
TEKNOLOGI
PERANGKAT PAKAI
The Solenoid Valve: An Electromagnet That Opens a Pipe
Youblob (generated from this blueprint's notebook) · CC0
Emma

Dibuat oleh

Emma

27. September 2026SE
7
0
0
0
0

The Solenoid Valve: An Electromagnet That Opens a Pipe

A relay lets a small current switch a large one. A solenoid valve does the same for a fluid: a coil round a tube pulls a soft-iron plunger that opens or closes an orifice, so a switch, a thermostat or a timer can turn water, air, gas or oil on and off without a hand on the valve. Washing machines, irrigation timers, compressors and boilers all use them. The Automatic Switch Company (ASCO) of New York is credited with making the first solenoid valves in 1910. This rung works out why a solenoid's pull depends so steeply on its air gap, why that limits a direct-acting valve's orifice, and how a pilot valve gets round it — then drives a real 12 V valve from a switch and measures when it will and will not open.
Pemula
About 3 hours

Instruksi

1

Pull against gap, and the orifice it can open

Memuat notebook Jupyter…
2

The same electromagnet, switching a current

A solenoid valve is an electromagnet pulling an armature, as in a relay. The embedded blueprint builds the relay the idea came from.
3

Measure a solenoid's pull against its gap

Take a small 12 V push-pull solenoid. Clamp it upright and hang its plunger from a spring scale, with a nut on the scale's hook so you can set the gap between the plunger's end and the coil's stop with feeler gauges. At each gap switch the coil on from the power supply and read the pull. Plot pull against gap: it rises steeply as the gap closes, as the notebook's $1/g^2$ says, then levels off as the iron saturates. Watch the coil current on the supply's meter: it does not change with the gap — the current sets the ampere-turns, the gap sets the pull.

Material untuk langkah ini:

SolenoidaSolenoida1 buah
Kabel JumperKabel Jumper1 buah

Alat yang dibutuhkan:

Sumber daya arus searahSumber daya arus searah
Neraca Pegas (Pengukur Gaya)Neraca Pegas (Pengukur Gaya)
Set pengukur celahSet pengukur celah
Ragum MejaRagum Meja
MultimeterMultimeter
4

Drive a real valve, and find where it stops opening

Plumb a 12 V solenoid valve between a garden hose (through a ball valve and pressure gauge) and an open outlet into a bucket, with the valve's arrow pointing downstream. Wire the coil to the power supply through a push button. Press the button and water flows; release it and it stops. Now close the ball valve until the gauge reads almost nothing and try again: many small 12 V valves are pilot-operated and will not open at all at very low pressure — they need a pressure difference to lift their diaphragm. Note the lowest pressure at which it opens, and check the valve's plate or data sheet for its minimum operating pressure.

Material untuk langkah ini:

12V Solenoid Valve - 19mm12V Solenoid Valve - 19mm1 buah
Selang tamanSelang taman1 buah
Katup bola kuninganKatup bola kuningan1 buah
Pita segel ulir PTFEPita segel ulir PTFE1 buah
Tombol tekanTombol tekan1 buah
AirAir20 liter

Alat yang dibutuhkan:

Sumber daya arus searahSumber daya arus searah
Pengukur TekananPengukur Tekanan
Kunci InggrisKunci Inggris
EmberEmber
5

A solenoid valve that will not behave

Solenoid valve faults in the order to check them.

Flow

Loading...
6

History and honest limits

The **Automatic Switch Company** (ASCO), founded in New York, is credited with the first solenoid valves, in 1910. Direct-acting and pilot-operated valves of every size now follow the same two patterns. **Honest limits.** The notebook's pull formula counts only the air gap and ignores the iron's own reluctance and leakage flux; real solenoids give less. A coil held on continuously warms, and its resistance and pull fall as it does. Never use a water valve for gas or fuel: those need valves certified for them.

Bahan

8

Alat yang Diperlukan

8
Estimasi total
Yang dibeli pembuatnya. Bahan tanpa harga didapat di tempat kamu membelinya.
$7.49

Blueprint terkait

Blueprint ini berbagi pengetahuan — teknik, bahan, atau prinsip

The Telegraph Relay

The Telegraph Relay

oleh EdFI

Elektronik

43
0
0
0
2
0
The Float Valve

The Float Valve

oleh MartinNO

TEKNOLOGI

34
0
0
0
1
0
One Way Only: The Check Valve and the Bang It Makes

One Way Only: The Check Valve and the Bang It Makes

oleh MartinNO

Alat

11
0
0
0
0
0
The Spool Valve: Steering Oil With a Sliding Rod

The Spool Valve: Steering Oil With a Sliding Rod

oleh EmmaSE

Mekanika

5
0
0
0
0
0
Ohm's Law at the Bench: Picking the Resistor That Saves the LED

Ohm's Law at the Bench: Picking the Resistor That Saves the LED

oleh VoltSE

Elektronik

23
0
0
0
0
0

CC0 Domain Publik

Cetak biru ini dirilis di bawah CC0. Anda bebas untuk menyalin, memodifikasi, mendistribusikan, dan menggunakan karya ini untuk tujuan apa pun, termasuk komersial, tanpa meminta izin.

Dukung Maker dengan membeli produk melalui Cetak Biru mereka di mana mereka mendapatkan Komisi Pembuat yang ditetapkan oleh Penjual, atau buat iterasi baru dari Cetak Biru ini dan masukkan sebagai koneksi di milik Anda sendiri.

Diskusi

(0)

Masuk untuk bergabung dengan diskusi

Memuat komentar...