कला
सौंदर्य और कल्याण
हस्तशिल्प
संस्कृति और इतिहास
मनोरंजन
पर्यावरण
खाद्य और पेय
रिवर्स इंजीनियरिंग
विज्ञान
खेल
प्रौद्योगिकी
पहनने योग्य
Ball Bearings: Races, Balls and Cage
Emma

द्वारा बनाया गया

Emma

11. अक्टूबर 2026SE
0
0
0
0
0

Ball Bearings: Races, Balls and Cage

A ball bearing has four parts: an outer race, an inner race, the balls that roll between them, and a cage that keeps the balls evenly spaced. Almost all of it is steel, usually 52100 (1% chromium, 1% carbon), which can be made very hard and tough by heat treating; 440C stainless is used where rust is a problem. The races are turned from tubing, the balls are cold headed from thick wire, both are hardened, tempered, ground and lapped to an almost mirror finish, and the cage is stamped from thin sheet. Even an inexpensive bearing's balls may be out of round by no more than 25 millionths of an inch; precision bearings allow five millionths.
उन्नत
Factory process

निर्देश

1

Turn the races

Cut the basic shape of both races from steel tubing on automatic lathe-like machines, leaving every dimension slightly oversize: the steel usually warps in heat treatment.

इस चरण के लिए सामग्री:

बेयरिंग स्टील ट्यूब (52100)बेयरिंग स्टील ट्यूब (52100)1 as required

आवश्यक उपकरण:

स्वचालित खराद मशीनस्वचालित खराद मशीन
2

Harden and temper the races

Heat to about 843 °C (1,550 °F) for up to several hours depending on size, then quench in oil: hard but brittle. Temper at about 149 °C (300 °F) and let cool in air: hard and tough.

आवश्यक उपकरण:

तेल में बुझाने वाली सतत कठोरीकरण भट्ठीतेल में बुझाने वाली सतत कठोरीकरण भट्ठी
टेम्परिंग ओवनटेम्परिंग ओवन
3

Grind and lap the races

The hardened steel is too hard to cut, so grind almost every surface: the fitting surfaces round, the sides flat. Grind the ball track, then lap it for several hours with a very fine abrasive slurry to an almost mirror finish.

इस चरण के लिए सामग्री:

लैपिंग कंपाउंडलैपिंग कंपाउंड1 as required

आवश्यक उपकरण:

बेयरिंग रेस ग्राइंडिंग मशीनबेयरिंग रेस ग्राइंडिंग मशीन
रेस लैपिंग मशीनरेस लैपिंग मशीन
4

Cold head the balls

Feed thick wire from a roll into a machine that cuts off a short piece and smashes both ends in toward the middle between two dies, without heating. The ball comes out with a ring of "flash" round its middle.

इस चरण के लिए सामग्री:

बेयरिंग स्टील तार (52100)बेयरिंग स्टील तार (52100)1 as required

आवश्यक उपकरण:

कोल्ड हेडिंग मशीनकोल्ड हेडिंग मशीन
5

Remove the flash

Run the balls many times round rough grooves between two cast-iron discs, one turning and one fixed, until the flash is gone and they are nearly round. Leave about 0.008 in (0.2 mm) for finishing.

आवश्यक उपकरण:

गोलियों की फ़्लैश हटाने की मशीनगोलियों की फ़्लैश हटाने की मशीन
6

Harden, grind and lap the balls

Heat treat and temper the balls like the races. Grind them in the same kind of disc machine with grinding wheels to within a few ten-thousandths of an inch, then lap them 8–10 hours on cast-iron wheels with lapping compound.

इस चरण के लिए सामग्री:

लैपिंग कंपाउंडलैपिंग कंपाउंड1 as required

आवश्यक उपकरण:

तेल में बुझाने वाली सतत कठोरीकरण भट्ठीतेल में बुझाने वाली सतत कठोरीकरण भट्ठी
टेम्परिंग ओवनटेम्परिंग ओवन
गोलियाँ घिसने की मशीनगोलियाँ घिसने की मशीन
गोलियाँ लैप करने की मशीनगोलियाँ लैप करने की मशीन
7

Stamp the cage

Stamp the cage halves from thin steel sheet and bend them to shape in a die. (Plastic cages are injection moulded instead.)

इस चरण के लिए सामग्री:

इस्पात की चादरइस्पात की चादर1 as required

आवश्यक उपकरण:

स्टैम्पिंग प्रेसस्टैम्पिंग प्रेस
8

Assemble

Put the inner race inside the outer race, pushed as far to one side as it goes, and drop the balls into the gap opposite. Centre the races and spread the balls evenly, fit the cage (steel cages riveted, plastic ones snapped in) and coat the bearing with rust preventive.

इस चरण के लिए सामग्री:

इस्पात की रिवेटइस्पात की रिवेट1 as required
जंगरोधी लेपजंगरोधी लेप1 as required

सामग्री

6

आवश्यक उपकरण

10

संबंधित ब्लूप्रिंट

ये ब्लूप्रिंट ज्ञान साझा करते हैं — तकनीक, सामग्री या सिद्धांत

CC0 पब्लिक डोमेन

यह ब्लूप्रिंट CC0 के तहत जारी किया गया है। आप बिना अनुमति माँगे इस कार्य को किसी भी उद्देश्य के लिए कॉपी, संशोधित, वितरित और उपयोग करने के लिए स्वतंत्र हैं।

उनके ब्लूप्रिंट के माध्यम से उत्पाद खरीदकर मेकर का समर्थन करें जहाँ वे मेकर कमीशन कमाते हैं जो विक्रेताओं द्वारा निर्धारित होता है, या इस ब्लूप्रिंट का नया संस्करण बनाएँ और राजस्व साझा करने के लिए इसे अपने ब्लूप्रिंट में कनेक्शन के रूप में शामिल करें।

चर्चा

(0)

लॉग इन करें चर्चा में शामिल होने के लिए

टिप्पणियाँ लोड हो रही हैं...