アート
美容とウェルネス
工芸
文化と歴史
エンターテインメント
環境
食品と飲料
リバースエンジニアリング
科学
スポーツ
テクノロジー
ウェアラブル
Waveguide and the Klystron
Penny

作成者

Penny

27. 8月 2026DK
34
0
0
0
0

Waveguide and the Klystron

Two problems appear together once a system works at centimetric wavelengths, and both are solved by abandoning ideas that had been correct for fifty years. Coaxial cable becomes hopeless — its dielectric absorbs and its inner conductor cooks, so the loss per metre becomes unaffordable. The answer is to delete the inner conductor entirely and send the wave down a hollow metal pipe, which sounds like it should short the signal out and does not, because above a certain frequency set by the pipe’s dimensions the wave propagates as a field pattern rather than as current in a wire. The second problem is that the magnetron is a superb transmitter and a useless receiver local oscillator, being neither tunable nor stable. The klystron solves that by velocity modulation — bunching a steady electron beam in time and letting the bunches deliver their energy to a second cavity downstream, again turning transit time from a defect into the mechanism.
上級者
6 hours

手順

1

Measure why coax fails at microwave frequencies

Establish the loss that forces the change.

  1. Measure the insertion loss of a known length of coaxial cable at 1 MHz.
  2. Repeat at 100 MHz, then as high as your equipment reaches.
  3. Plot loss per metre against frequency.

Loss climbs steadily and then steeply. Two mechanisms are at work and both worsen with frequency: the skin effect confines current to an ever-thinner layer on the conductor surface, raising effective resistance; and the dielectric between the conductors absorbs energy directly, an effect that grows roughly in proportion to frequency.

The inner conductor is the real casualty. It is thin, it carries the full current, it is wrapped in insulation, and it therefore has nowhere to send its heat.

This is why microwave systems are built from rigid plumbing rather than cable, and why a satellite dish has its low-noise block mounted at the feed rather than indoors — you convert to a lower frequency at the antenna precisely so the run back to the receiver can be ordinary cable.

このステップの材料:

Coaxial Cable (RG-58, 50 m)Coaxial Cable (RG-58, 50 m)1 reel
Graph PaperGraph Paper1 pad

必要な工具:

Signal GeneratorSignal Generator
Spectrum Analyser / FFT SoftwareSpectrum Analyser / FFT Software
Antenna Analyser (VSWR Meter)Antenna Analyser (VSWR Meter)
Digital Multimeter (Lab Grade)Digital Multimeter (Lab Grade)
Digital Caliper 6-InchDigital Caliper 6-Inch
Clear Safety GlassesClear Safety Glasses
2

Build a rectangular waveguide and find its cutoff

A hollow pipe is a high-pass filter whose corner frequency is set by its width.

  1. Make a rectangular waveguide section from sheet brass or copper — a good size for experiment is roughly 22 × 10 mm, which works above about 6.5 GHz.
  2. Fit a coupling probe at each end: a short quarter-wave pin projecting into the guide.
  3. Sweep frequency and measure transmission from end to end.
  4. Find the frequency below which nothing gets through.

Below the cutoff frequency the guide transmits nothing at all; above it, transmission is efficient. Cutoff for the dominant mode occurs when the free-space wavelength is twice the guide’s WIDE dimension — so the wide side alone sets the low-frequency limit, and the narrow side does not enter into it.

The reason a pipe does not short the signal is worth stating plainly: there is no inner conductor, so there is no circuit to short. The wave travels as a pattern of electric and magnetic fields that must satisfy the boundary condition that electric field is perpendicular to a conducting wall. Only certain patterns can do that, and only above a certain frequency does any pattern fit.

Reverse-engineering note: waveguide is always specified by its internal dimensions, never by an impedance, and its interior is often silver-plated. The plating is not decorative — at these frequencies all the current flows within a few micrometres of the surface, so the surface metal is the ONLY metal that matters.

このステップの材料:

Brass Sheet (0.5mm)Brass Sheet (0.5mm)1
Copper Block (Cavity Stock)Copper Block (Cavity Stock)1
Silver Conductive PaintSilver Conductive Paint1 tube

必要な工具:

Signal GeneratorSignal Generator
Spectrum Analyser / FFT SoftwareSpectrum Analyser / FFT Software
Antenna Analyser (VSWR Meter)Antenna Analyser (VSWR Meter)
Digital Caliper 6-InchDigital Caliper 6-Inch
MicrometerMicrometer
File SetFile Set
Drill PressDrill Press
HacksawHacksaw
Soldering StationSoldering Station
Clear Safety GlassesClear Safety Glasses
3

Find the standing wave and the guide wavelength

Measure inside the guide, and discover the wavelength is not what you expect.

  1. Cut a narrow slot along the CENTRE of the guide’s broad wall, parallel to the axis.
  2. Insert a small probe on a sliding carriage and feed its output to a detector.
  3. Terminate the far end with a short circuit and slide the probe along, recording detected level against position.
  4. Measure the distance between adjacent minima and double it.

The guide wavelength is LONGER than the free-space wavelength at the same frequency, and it stretches toward infinity as you approach cutoff. The wave is effectively zig-zagging down the pipe rather than travelling straight, so its progress along the axis is slower than its progress through space.

The slot position is not arbitrary and this is the detail worth remembering: a longitudinal slot in the centre of the broad wall cuts no current lines, so it does not disturb the fields and does not radiate. The same slot cut across the guide would interrupt the wall currents and turn the instrument into an antenna. Slotted lines are cut this way on purpose, and slotted-waveguide antennas are cut the opposite way on purpose.

This is the microwave version of the standing-wave measurement, and before network analysers existed it was how impedance was measured: the ratio of maximum to minimum gives VSWR, and the position of the minimum gives the phase.

このステップの材料:

Brass Sheet (0.5mm)Brass Sheet (0.5mm)1
Germanium Diode (1N34A)Germanium Diode (1N34A)2
Graph PaperGraph Paper1 pad

必要な工具:

Signal GeneratorSignal Generator
Spectrum Analyser / FFT SoftwareSpectrum Analyser / FFT Software
Antenna Analyser (VSWR Meter)Antenna Analyser (VSWR Meter)
Digital Caliper 6-InchDigital Caliper 6-Inch
MicrometerMicrometer
File SetFile Set
Digital Multimeter (Lab Grade)Digital Multimeter (Lab Grade)
Clear Safety GlassesClear Safety Glasses
4

Bunch a beam in time, and understand the klystron

Velocity modulation converts a steady beam into a pulsating one without any grid switching it.

  1. Sketch the two-cavity klystron: an electron gun, a buncher cavity, a drift space, a catcher cavity and a collector.
  2. Follow one electron through: the buncher cavity’s RF field either speeds it up or slows it down depending on when it arrives.
  3. Reason about what happens to a stream of such electrons after they travel down the drift space.

Electrons that were speeded up catch those that were slowed down, so by the end of the drift space the uniform stream has sorted itself into dense bunches. No electron has been created or removed — they have merely been redistributed in time — and those bunches, arriving periodically at the catcher cavity, drive it hard and deliver useful RF power.

Notice what has happened to the transit-time problem. In a triode, transit time destroys control. Here the drift time IS the mechanism, and it is chosen deliberately: too short and the bunches have not formed, too long and they have passed through each other and dispersed.

The reflex klystron used in radar receivers folds this idea in half — one cavity, and a repeller electrode that turns the beam around and sends it back through the same cavity at the right moment. Fewer parts, easily tunable by varying the repeller voltage, and stable enough to serve as a local oscillator, which is exactly what the magnetron could not do.

このステップの材料:

Copper Block (Cavity Stock)Copper Block (Cavity Stock)1
Graph PaperGraph Paper1 pad

必要な工具:

Digital Caliper 6-InchDigital Caliper 6-Inch
MicrometerMicrometer
Digital Multimeter (Lab Grade)Digital Multimeter (Lab Grade)
Oscilloscope 2-Channel 100MHzOscilloscope 2-Channel 100MHz
Spectrum Analyser / FFT SoftwareSpectrum Analyser / FFT Software
Clear Safety GlassesClear Safety Glasses
5

Make a horn, and close the loop back to the antenna

The wave has to leave the pipe and enter free space, and a sudden opening does that badly.

  1. Terminate a waveguide with a plain open end and measure the reflected power.
  2. Now fit a flared horn — a gradual expansion from guide dimensions to a much larger aperture.
  3. Measure reflected power again.
  4. Map the radiation pattern of both, as you did for the dipole earlier in this batch.

The abrupt opening reflects a substantial fraction back down the guide; the flared horn reflects very little and produces a clean, narrow beam. The horn is an impedance transformer — it changes the wave’s impedance gradually from that of the guide to that of free space, and gradual is the entire point.

That principle has appeared repeatedly in this batch under different names: the balun matching a dipole to coax, the IF transformer’s coupling, the tapered cable joint in the power batch. Wherever two media meet, an abrupt transition reflects and a gradual one does not.

And this is where the batch closes. The horn feeding a parabolic reflector is the standard microwave antenna — the dish is a mirror, the horn is the source at its focus, and beamwidth is set by dish diameter in wavelengths, exactly the same relationship that governed the Yagi. From the tuned circuit to the parabolic dish, every step has been the same two questions: how do you select one frequency, and how do you get energy across a boundary without losing it.

このステップの材料:

Brass Sheet (0.5mm)Brass Sheet (0.5mm)2
Aluminium Sheet (0.5mm)Aluminium Sheet (0.5mm)1
Graph PaperGraph Paper1 pad

必要な工具:

Signal GeneratorSignal Generator
Spectrum Analyser / FFT SoftwareSpectrum Analyser / FFT Software
Antenna Analyser (VSWR Meter)Antenna Analyser (VSWR Meter)
RF Power Density MeterRF Power Density Meter
Digital Caliper 6-InchDigital Caliper 6-Inch
File SetFile Set
HacksawHacksaw
Tape Measure (5 m)Tape Measure (5 m)
Clear Safety GlassesClear Safety Glasses

材料

7

必要な工具

14

関連ブループリント

これらのブループリントは知識を共有しています — 技術、材料、原理

CC0 パブリックドメイン

このブループリントはCC0で公開されています。許可を求めずに、自由にコピー、修正、配布、あらゆる目的で使用できます。

メイカーを応援するには、ブループリント経由で製品を購入してください。メイカーには メイカーコミッション がベンダーにより設定されています。または、このブループリントの新しいイテレーションを作成し、自分のブループリントにコネクションとして含めて収益を共有できます。

ディスカッション

(0)

ログイン してディスカッションに参加

コメントを読み込み中...