УРЛАГ
ГОО САЙХАН БА ЭРҮҮЛ МЭНД
ГАРААР ХИЙСЭН
СОЁЛ БА ТҮҮХ
ҮЗВЭР НААДАМ
БАЙГАЛЬ ОРЧИН
ХООЛ БА УНДАА
УРВУУ ИНЖЕНЕРЧЛЭЛ
ШИНЖЛЭХ УХААН
СПОРТ
ТЕХНОЛОГИ
ӨМСДӨГ ХЭРЭГСЭЛ
Ball Bearings: Races, Balls and Cage
Emma

Зохиогч

Emma

11. Аравдугаар сар 2026SE
21
0
0
0
0

Ball Bearings: Races, Balls and Cage

A ball bearing has four parts: an outer race, an inner race, the balls that roll between them, and a cage that keeps the balls evenly spaced. Almost all of it is steel, usually 52100 (1.5% chromium, 1% carbon), which can be made very hard and tough by heat treating; 440C stainless is used where rust is a problem. The races are turned from tubing, the balls are cold headed from thick wire, both are hardened, tempered, ground and lapped to an almost mirror finish, and the cage is stamped from thin sheet. Even an inexpensive bearing's balls may be out of round by no more than 25 millionths of an inch; precision bearings allow five millionths.
Дээд шат
Factory process

Зааварчилгаа

1

Turn the races

Cut the basic shape of both races from steel tubing on automatic lathe-like machines, leaving every dimension slightly oversize: the steel usually warps in heat treatment.

Энэ алхмын материал:

Холхивчийн гангийн хоолой (52100)Холхивчийн гангийн хоолой (52100)1 as required

Шаардлагатай багаж:

Автомат токарийн машинАвтомат токарийн машин
2

Harden and temper the races

Heat to about 843 °C (1,550 °F) for up to several hours depending on size, then quench in oil: hard but brittle. Temper at about 149 °C (300 °F) and let cool in air: hard and tough.

Шаардлагатай багаж:

Тосонд хатууруулдаг тасралтгүй зуухТосонд хатууруулдаг тасралтгүй зуух
Хатуулаг тохируулах зуухХатуулаг тохируулах зуух
3

Grind and lap the races

The hardened steel is too hard to cut, so grind almost every surface: the fitting surfaces round, the sides flat. Grind the ball track, then lap it for several hours with a very fine abrasive slurry to an almost mirror finish.

Шаардлагатай багаж:

Холхивчийн цагираг зүлгэх машинХолхивчийн цагираг зүлгэх машин
Замыг өнгөлөн тааруулах машинЗамыг өнгөлөн тааруулах машин
Тааруулах зутанТааруулах зутан
4

Cold head the balls

Feed thick wire from a roll into a machine that cuts off a short piece and smashes both ends in toward the middle between two dies, without heating. The ball comes out with a ring of "flash" round its middle.

Энэ алхмын материал:

Холхивчийн гангийн утас (52100)Холхивчийн гангийн утас (52100)1 as required

Шаардлагатай багаж:

Хүйтнээр толгойлох машинХүйтнээр толгойлох машин
5

Remove the flash

Run the balls many times round rough grooves between two cast-iron discs, one turning and one fixed, until the flash is gone and they are nearly round. Leave about 0.008 in (0.2 mm) for finishing.

Шаардлагатай багаж:

Бөмбөлгийн өнгөр авах машинБөмбөлгийн өнгөр авах машин
6

Harden, grind and lap the balls

Heat treat and temper the balls like the races. Grind them in the same kind of disc machine with grinding wheels to within a few ten-thousandths of an inch, then lap them 8–10 hours on cast-iron wheels with lapping compound.

Шаардлагатай багаж:

Тосонд хатууруулдаг тасралтгүй зуухТосонд хатууруулдаг тасралтгүй зуух
Хатуулаг тохируулах зуухХатуулаг тохируулах зуух
Бөмбөлөг зүлгэх машинБөмбөлөг зүлгэх машин
Бөмбөлөг өнгөлөн тааруулах машинБөмбөлөг өнгөлөн тааруулах машин
Тааруулах зутанТааруулах зутан
7

Stamp the cage

Stamp the cage halves from thin steel sheet and bend them to shape in a die. (Plastic cages are injection moulded instead.)

Энэ алхмын материал:

Ган хуудасГан хуудас1 as required

Шаардлагатай багаж:

Штамплах шахуургаШтамплах шахуурга
8

Assemble

Put the inner race inside the outer race, pushed as far to one side as it goes, and drop the balls into the gap opposite. Centre the races and spread the balls evenly, fit the cage (steel cages riveted, plastic ones snapped in) and coat the bearing with a thin film of petroleum jelly against rust.

Энэ алхмын материал:

Ган риветГан ривет1 as required
ВазелинВазелин1 as required

Материал

5

Шаардлагатай багаж

11

Холбоотой загварууд

Эдгээр загварууд мэдлэг хуваалцдаг — арга техник, материал эсвэл зарчим

CC0 Нийтийн домэйн

Энэ загвар CC0 дор гаргагдсан. Та зөвшөөрөл авахгүйгээр хуулах, өөрчлөх, түгээх, ашиглах боломжтой.

Загвараар дамжуулан бүтээгдэхүүн худалдаж авч Бүтээгчийг дэмжээрэй Бүтээгчийн шимтгэл Борлуулагчаар тогтоосон, эсвэл энэ загварын шинэ хувилбар үүсгэж орлогоо хуваахын тулд өөрийн загварт холбоос болгон оруулна уу.

Хэлэлцүүлэг

(0)

Нэвтрэх хэлэлцүүлэгт нэгдэхийн тулд

Сэтгэгдлүүдийг ачаалж байна...