УРЛАГ
ГОО САЙХАН БА ЭРҮҮЛ МЭНД
ГАРААР ХИЙСЭН
СОЁЛ БА ТҮҮХ
ҮЗВЭР НААДАМ
БАЙГАЛЬ ОРЧИН
ХООЛ БА УНДАА
УРВУУ ИНЖЕНЕРЧЛЭЛ
ШИНЖЛЭХ УХААН
СПОРТ
ТЕХНОЛОГИ
ӨМСДӨГ ХЭРЭГСЭЛ
Glass Saw: Rigid Diamond Wire Ring Driven by Its Rim
Martin

Зохиогч

Martin

23. Аравдугаар сар 2026NO
2
0
0
0
0

Glass Saw: Rigid Diamond Wire Ring Driven by Its Rim

Jesse Cogswell's ring saw (US 4,576,139, 1986) for glass, ceramics and stone. The blade is a rigid circle of wire coated with bonded diamond, standing upright through a cutting table. A rubber-tyred wheel on the motor drives it by friction round its own rim at 3000 ft/min or more, and twelve guide wheels on slots round an aluminium back-plate hold it true. Because it cuts with any part of its rim, the work can be turned freely for curves and inside shapes; a sponge in a water tray wets the wire. The patent sizes the ring from the thickest work to be cut (8 in ring for 3/16 in); the notebook does the sums. The picture: the patent's Fig. 1.
Дээд шат
3 days

Зааварчилгаа

1

Cut and brace the back-plate

Cut the back-plate (2A) from aluminium plate, its upper part curved as an arc to shield the saw, stiffened by an angle (2B) along the top and a flat splatter strip (2C) at the front. Bolt on two front struts (21, 21A) and two side struts (22) and bolt them to the base. Ours: drill press.

Энэ алхмын материал:

Хөнгөн цагаан хавтанХөнгөн цагаан хавтан1 ширхэг
Хөнгөн цагаан буланХөнгөн цагаан булан1 ширхэг
Зургаан талт толгойт болт - зэрэглэл 8.8Зургаан талт толгойт болт - зэрэглэл 8.81 ширхэг

Шаардлагатай багаж:

Суурин өрөмСуурин өрөм
Тохируулгатай түлхүүрТохируулгатай түлхүүр
2

Cut the wheel-slider apertures

Cut slots (32) through the back-plate's arc at 0, 30, 60, 90, 120, 210, 240, 270, 300 and 330° round the ring's centre: two slots at 90° and 210° for the guide pairs, one at each of the others. The slots let each guide wheel slide to the ring.

Шаардлагатай багаж:

Суурин өрөмСуурин өрөм
3

Assemble the guide wheels

For each of the twelve guide wheels, stretch two rubber O-rings (27) into the grooves of a bearing wheel (26) with sealed roller bearings, and mount it on a shoulder bolt (28) with a washer, lockwasher and nut.

Энэ алхмын материал:

Чиглүүлэх өнхрүүшЧиглүүлэх өнхрүүш12 ширхэг
О-цагирагО-цагираг24 ширхэг
Мөрт шурагМөрт шураг12 ширхэг
Хавтгай угаагуурХавтгай угаагуур12 ширхэг
Spring WasherSpring Washer12 ширхэг
Зургаан талт эрэгЗургаан талт эрэг12 ширхэг

Шаардлагатай багаж:

Тохируулгатай түлхүүрТохируулгатай түлхүүр
4

Turn the drive wheel

Turn an aluminium disk with a hub, a bored axle hole and a deep groove round its rim, and seat a large rubber O-ring (23) in the groove as its driving tyre. Ours: lathe.

Энэ алхмын материал:

Хөнгөн цагаан хавтанХөнгөн цагаан хавтан1 ширхэг
О-цагирагО-цагираг1 ширхэг

Шаардлагатай багаж:

Металл эрэгМеталл эрэг
5

Mount the motor and drive axle

Strap the electric motor (51) onto its pillow block (50) with fastening bands (52) and bolt the block to the base. Fix the drive wheel on the motor's axle (24) and carry the axle's end in an axle pillow block (24A, 24B).

Энэ алхмын материал:

Цахилгаан моторЦахилгаан мотор1 ширхэг
Хөдөлгүүр бэхлэх туузХөдөлгүүр бэхлэх тууз2 ширхэг
Холхивчийн суурьХолхивчийн суурь2 ширхэг
Ган голГан гол1 ширхэг
Зургаан талт толгойт болт - зэрэглэл 8.8Зургаан талт толгойт болт - зэрэглэл 8.81 ширхэг

Шаардлагатай багаж:

Тохируулгатай түлхүүрТохируулгатай түлхүүр
6

Fit the ring and its guides

Stand the ring saw on the drive wheel's tyre. Bolt the guide wheels through their slots: each pair with a tension spring between its two wheels, each single with a spring to the back-plate's lower rim, the one at 330° pressing the ring onto the drive wheel. Set them against the ring, then tighten the nuts. Fit two horizontal roller-guides (17) at 150°, sprung together, just before the cut.

Энэ алхмын материал:

Алмазан цагираг хөрөөний ирАлмазан цагираг хөрөөний ир1 ширхэг
Таталтын пүршТаталтын пүрш11 ширхэг
Чиглүүлэх өнхрүүшЧиглүүлэх өнхрүүш2 ширхэг

Шаардлагатай багаж:

Тохируулгатай түлхүүрТохируулгатай түлхүүр
7

Fit the table, tray and sponge

Bolt the water tray (46) on four bracket supports (19, 20) by its four studs; put a ring-shaped sponge (47) in it and the cutting table (44) over it, the ring passing through centre holes reached by slots offset half an inch from a radius. Set the table top below the ring's centre line by the thickest work you will cut. Add water to the tray.

Энэ алхмын материал:

ТавиурТавиур1 ширхэг
Далайн хөвөнДалайн хөвөн1 ширхэг
Хөнгөн цагаан хавтанХөнгөн цагаан хавтан1 ширхэг
УсУс1 batch

Шаардлагатай багаж:

Тохируулгатай түлхүүрТохируулгатай түлхүүр
8

Fit the face shield and drip pan

Bolt the shield arm (41) to the back-plate and pivot a clear acrylic face shield (43) in its holder (42) on a locking screw. The base is a catchment for the coolant with a drain hole in one corner.

Энэ алхмын материал:

Акрилын хавтанАкрилын хавтан1 ширхэг
Хөнгөн цагаан хавтанХөнгөн цагаан хавтан1 ширхэг
Дусал тосгуурДусал тосгуур1 ширхэг

Шаардлагатай багаж:

Тохируулгатай түлхүүрТохируулгатай түлхүүр
9

Ring size and drive speed

Jupyter дэвтэр ачаалж байна…

Материал

20

Шаардлагатай багаж

3

Энэ загвараар хийдэг

CC0 Нийтийн домэйн

Энэ загвар CC0 дор гаргагдсан. Та зөвшөөрөл авахгүйгээр хуулах, өөрчлөх, түгээх, ашиглах боломжтой.

Загвараар дамжуулан бүтээгдэхүүн худалдаж авч Бүтээгчийг дэмжээрэй Бүтээгчийн шимтгэл Борлуулагчаар тогтоосон, эсвэл энэ загварын шинэ хувилбар үүсгэж орлогоо хуваахын тулд өөрийн загварт холбоос болгон оруулна уу.

Хэлэлцүүлэг

(0)

Нэвтрэх хэлэлцүүлэгт нэгдэхийн тулд

Сэтгэгдлүүдийг ачаалж байна...