ARTE
BELLEZA Y BIENESTAR
ARTESANÍA
CULTURA E HISTORIA
ENTRETENIMIENTO
MEDIO AMBIENTE
COMIDA Y BEBIDAS
FUTURO VERDE
INGENIERÍA INVERSA
CIENCIAS
DEPORTES
TECNOLOGÍA
TECNOLOGÍA VESTIBLE
Binding a Besom Broom — The Birch-Twig Broom on a Hazel Handle
The besom is the oldest broom: a fat bundle of springy birch twigs bound around a hazel or ash handle. Every household swept with one, and it cost nothing but a walk to the woods. There are no nails and no glue — the head is held by tight withy bindings and a single wooden peg, and it only grips harder as the birch dries and shrinks. This blueprint binds a besom from cut brush to finished broom using hand tools alone.
Principiante
3
Instrucciones
1
1
Cut the birch brush
Cut the birch brush
Cut generous bundles of thin, whippy birch twigs — the 'brush'. Winter-cut birch, taken when the tree is bare, is springiest and lasts longest. Keep the twigs long and unbroken.
Materiales para este paso:
Birch Brush1 manojoHerramientas necesarias:
Billhook2
2
Wilt the twigs supple
Wilt the twigs supple
Lay the cut brush somewhere cool for a few days until the twigs lose their brittleness and bend without snapping. Supple twigs pack tightly and bind without cracking.
Materiales para este paso:
Birch Brush1 manojo3
3
Cut and point the handle
Cut and point the handle
Cut a straight length of hazel or ash about a thumb-and-a-half thick for the handle. Trim it clean and whittle one end to a long blunt point so the brush seats around it.
Materiales para este paso:
Green Wood Poles (1-2m)1 piezaHerramientas necesarias:
Billhook
Knife4
4
Soak the binding withies
Soak the binding withies
Soak split willow withies in water until they are fully flexible. These flexible ties will cinch the brush to the handle; they must bend sharply without breaking.
Materiales para este paso:
Willow Withy2 piezas
Water5 litros5
5
Lay the brush around the handle
Lay the brush around the handle
Stand the pointed handle upright and lay birch twigs evenly all the way around it, butt ends up along the handle and tips hanging down. Keep the bundle even so the finished broom is not lopsided.
Materiales para este paso:
Birch Brush1 manojo6
6
Bind the top band
Bind the top band
Squeeze the twigs tight against the handle and wind a soaked withy hard around the bundle near the top of the brush. Pull it as tight as you can and twist and tuck the ends to lock the band.
Materiales para este paso:
Willow Withy1 pieza7
7
Bind the second band
Bind the second band
Wind a second withy band about a hand's width below the first and cinch it just as tight. Two bands stop the brush from splaying and spread the sweeping wear.
Materiales para este paso:
Willow Withy1 pieza8
8
Peg the head to the handle
Peg the head to the handle
Whittle a small hardwood peg. Start a hole through the handle between the bindings with the awl, then drive the peg through with the mallet so the head can never slide off the handle.
Herramientas necesarias:
Knife
Awl
Wooden Mallet9
9
Trim the sweeping end
Trim the sweeping end
Trim the hanging tips of the brush level across the bottom with the billhook so the broom meets the floor evenly and sweeps cleanly.
Herramientas necesarias:
Billhook10
10
Season the besom
Season the besom
Stand the finished besom in a dry place to season. As the birch dries it stiffens into a firm brush and the withy bindings shrink even tighter — the broom is ready to sweep.
Materiales
4- 3 manojosMarcador de posición
- 1 piezaMarcador de posición
- 4 piezasMarcador de posición
Materiales de Blueprints conectados
Recommended for this build
Products makers often use with builds like this one.
Hand SawUsed together and in similar builds
Cloth (Straining)Frequently used with this build's materials
Sloyd Carving KnifeFrequently used with this build's materials
Binding RopeUsed together and in similar builds
Dowel RodUsed together and in similar builds
Beech LumberUsed together and in similar builds
HacksawFrequently used with this build's materials
Large Cooking PotFrequently used with this build's materialsBlueprints relacionados
Estos blueprints comparten conocimiento — técnicas, materiales o principios
Related blueprints
Other builds that share materials, tools, or techniques with this one.
Building a Charango — The Little High Lute of the Andes
Building a Roman Groma — The Surveying Instrument That Laid Out an Empiretools
Building a Macadam Road — Cheap, Dry Highways from Small Broken StoneENGINEERING
Blowing a Glass Bottle by Hand — Free-Blown Vessel ShapingGlassworking
Building a Bloomery & Smelting Iron — The Iron Agematerials/metals
Making a Hammerstone — The First Tool in Human Historystoneworking
CC0 Dominio público
Este Blueprint se publica bajo CC0. Eres libre de copiar, modificar, distribuir y usar este trabajo para cualquier propósito, sin pedir permiso.
Apoya al Maker comprando productos a través de su Blueprint, donde gana una Comisión del Maker establecida por los vendedores, o crea una nueva iteración de este Blueprint e inclúyela como conexión en tu propio Blueprint para compartir ingresos.