IṢẸ́ ỌNÀ
ẸWÀ ÀTI ÌLERA
IṢẸ́ ỌWỌ́
ÀṢÀ ÀTI ÌTÀN
ÌṢERÉ
ÀYÍKÁ
OÚNJẸ ÀTI OHUN MÍMU
REVERSE ENGINEERING
SÁYẸ́ǸSÌ
ERÉ ÌDÁRAYÁ
ÌMỌ̀-Ẹ̀RỌ
ÀWỌN OHUN WÍWỌ̀
Ebonite (Hard Rubber)
Mary

Ṣẹ́dá nipasẹ̀

Mary

22. Oṣù Kẹsàn 2026FI
0
0
0
0
0

Ebonite (Hard Rubber)

Vulcanised rubber is rubber with a few sulphur bridges between its chains. Keep adding sulphur and the bridges multiply until the chains cannot move at all: the soft, stretchy material turns into a hard black solid you can turn on a lathe, polish like ebony and use as an electrical insulator. **US 8,075**, "Improvement in the Manufacture of India Rubber", Nelson Goodyear (brother of Charles), granted 6. May 1851, claims "the combining of india-rubber and sulphur… for making a hard and inflexible substance hitherto unknown": about equal parts by weight, heated to 260–275 °F for three to six hours. It was one of the first rigid materials made by chemically changing a natural polymer, over half a century before Bakelite. **You turn a part from commercial ebonite rod and measure what the sulphur did** — its density, and its charge when rubbed. Curing ebonite needs a heated press and releases hydrogen sulphide, so the blueprint starts from finished rod; the notebook does the chemistry.
Àárín
3 hours

Ìlànà

1

Cut the blank

Clamp 20 mm ebonite rod in the vise between soft jaws. Saw off 60 mm. Ebonite chips like hard wood; saw slowly to avoid cracking the end.

Àwọn ohun èlò fún ìgbésẹ̀ yìí:

Ọ̀pá eboniteỌ̀pá ebonite1 ẹyọ

Àwọn irinṣẹ́ tí a nílò:

Ayùn IrinAyùn Irin
Ìdìmú TábìlìÌdìmú Tábìlì
Ìwọ̀n IrinÌwọ̀n Irin
Gílásì Ààbò Tí Ó Mọ́Gílásì Ààbò Tí Ó Mọ́
2

Chuck and face

Grip 20 mm of the blank in the lathe's 3-jaw chuck. Face the end square with a sharp HSS tool at about 800 rpm, light cuts.

Àwọn irinṣẹ́ tí a nílò:

Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
Àpò ohun èlò lathe (HSS)Àpò ohun èlò lathe (HSS)
Gílásì Ààbò Tí Ó Mọ́Gílásì Ààbò Tí Ó Mọ́
Ìbòjú ErukuÌbòjú Eruku
3

Turn to 16 mm

Turn 40 mm of length down to 16.0 mm. Check with the caliper every pass. The chips smell of sulphur - that is the bonded sulphur you measure later.

Àwọn irinṣẹ́ tí a nílò:

Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
Àpò ohun èlò lathe (HSS)Àpò ohun èlò lathe (HSS)
Òṣùwọ̀n Kálípà Díjítà Ìnṣì 6Òṣùwọ̀n Kálípà Díjítà Ìnṣì 6
4

Drill the bore

Spot the centre with a centre drill, then drill 3 mm through 35 mm from the tailstock. Clear chips every 5 mm - ebonite heats and gums if packed.

Àwọn irinṣẹ́ tí a nílò:

Ìdìpọ̀ ilẹ̀kùn ààrinÌdìpọ̀ ilẹ̀kùn ààrin
Ìdìpọ̀ irin ìlù nínú àpótíÌdìpọ̀ irin ìlù nínú àpótí
Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
5

Taper the grip

Set the compound to a shallow angle and taper 25 mm from 16 mm down to 10 mm. This is a fountain-pen grip section, the job ebonite still does today.

Àwọn irinṣẹ́ tí a nílò:

Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
Àpò ohun èlò lathe (HSS)Àpò ohun èlò lathe (HSS)
Òṣùwọ̀n Kálípà Díjítà Ìnṣì 6Òṣùwọ̀n Kálípà Díjítà Ìnṣì 6
6

Sand and polish

At low speed, sand 400 then 800 grit, then run the Micro-Mesh grits in order. Finish with polishing compound on a cloth. Ebonite takes a deep gloss without lacquer.

Àwọn ohun èlò fún ìgbésẹ̀ yìí:

Bébà ÌfáBébà Ìfá2 ewé
Ohun ìdánOhun ìdán5 g

Àwọn irinṣẹ́ tí a nílò:

Ètò Ìfọwọ́ra Àwọ̀n Kékeré (Ìwọ̀n 9)Ètò Ìfọwọ́ra Àwọ̀n Kékeré (Ìwọ̀n 9)
Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
Ìbòjú ErukuÌbòjú Eruku
7

Part off

Part off at 45 mm with the parting tool. Chamfer the cut end by hand with 800 grit.

Àwọn irinṣẹ́ tí a nílò:

Àpò ohun èlò lathe (HSS)Àpò ohun èlò lathe (HSS)
Ẹ̀rọ Ìyí IrinẸ̀rọ Ìyí Irin
8

Measure the density

Weigh the part. Drop it into 50 ml of water in the graduated cylinder and read the rise. Do the same with a bundle of rubber bands. Enter both in the notebook.

Àwọn ohun èlò fún ìgbésẹ̀ yìí:

Okùn rọ́bàOkùn rọ́bà1 àkópọ̀

Àwọn irinṣẹ́ tí a nílò:

Òṣùwọ̀n Díjítà PípéÒṣùwọ̀n Díjítà Pípé
Silinda òǹwọ̀nSilinda òǹwọ̀n
9

Rub it and pick up paper

Tear tissue into 5 mm scraps. Rub the ebonite 10 strokes on wool felt and hold it 2 cm above the scraps. Repeat with an acrylic offcut. Count scraps lifted by each.

Àwọn ohun èlò fún ìgbésẹ̀ yìí:

Ìwé tissue tí kò ní asíìdìÌwé tissue tí kò ní asíìdì1 ewé
Pẹlẹbẹ AkrílíìkìPẹlẹbẹ Akrílíìkì1 ẹyọ

Àwọn irinṣẹ́ tí a nílò:

Aṣọ irun àgùtàn tí a lẹ̀Aṣọ irun àgùtàn tí a lẹ̀
10

The sulphur arithmetic

Ń ṣí ìwé Jupyter…
11

History & Context

**What the patent specifies:** rubber and sulphur in about equal parts (or 2 : 1 with magnesia or lime), 260–275 °F, three to six hours. **Modern build (derived):** commercial ebonite rod, typically 25–32 % sulphur - the notebook shows why more than about 32 % cannot bond. Ebonite was named for ebony, which it replaced in combs, pipe stems and instrument parts. It became a standard insulator of the electrical age and is still preferred for fountain-pen feeds because ink wets it. Its limits: it softens with heat, fades to brown and smells of sulphur in sunlight as the surface oxidises, and is brittle under impact.

Àwọn ohun-èlò

6

Àwọn irinṣẹ́ tó nílò

14

Blueprint tó jọra

Àwọn blueprint wọ̀nyí pín ìmọ̀ — ọ̀nà, ohun-èlò tàbí ìlànà

CC0 Àgbègbè Gbogbogbò

Blueprint yìí ti jáde lábẹ́ CC0. O lè ṣe àdàkọ, yí padà, pín, àti lò láìsí ìyọ̀ǹda.

Ṣàtìlẹ́yìn Olùṣẹ́dá nípa rírà àwọn ọjà nipasẹ̀ Blueprint wọn Ẹ̀san Olùṣẹ́dá tí àwọn Olùtajà gbé kalẹ̀, tàbí ṣẹ̀dá àtúnṣe tuntun ti Blueprint yìí kí o sì fi sínú Blueprint rẹ gẹ́gẹ́ bí ìsopọ̀ láti pín owó-wíwọlé.

Ìfọ̀rọ̀wérọ̀

(0)

Wọlé láti dara pọ̀ mọ́ ìfọ̀rọ̀wérọ̀

Ń gbé àwọn ọ̀rọ̀ wọlé...