Pakikipagtulungan
SINING
BEAUTY AT WELLNESS
CRAFTS
KULTURA AT KASAYSAYAN
LIBANGAN
KAPALIGIRAN
PAGKAIN AT INUMIN
REVERSE ENGINEERING
AGHAM
ISPORTS
TEKNOLOHIYA
MGA WEARABLE
Normal Butane: the 0 °C Cut of the Lightest Gasoline, Distilled Twenty Times in the Cold (Mabery & Hudson 1897)
The lightest gasoline still holds butane, a gas that boils at about 0 °C. Distil it again and again through a condenser packed in a freezing mixture, and the butane gathers as a cut between -2 and 2 °C.
Result: 300 grams within -2 to 2 °C, specific gravity 0.6029 at 0 °C, vapour density 2.07 (2.01 calculated for butane). Very little came over below -10 °C.
Note: Mabery & Hudson named this cut isobutane. By the boiling points in Ipatieff & Pines, US 2,318,226 (normal butane +0.5 °C, isobutane -10.5 °C), a cut at 0 °C is normal butane, and it is built here as such.
Source: Mabery & Hudson, Proc. Amer. Acad. 32 (1897), pp. 101-111. Not given: the freezing mixture, how the butane was stored. Extremely flammable: no flame near. Picture drawn by Youblob.
Dalubhasa
3 months
Mga Tagubilin
1
1
Take the lightest gasoline
Take the lightest gasoline
Start from the most volatile gasoline you can get. Mabery & Hudson used 88° and 92° Baumé gasoline, the second distillate of Pennsylvania and Ohio naphtha, collected at the refinery in lots of 45 litres while the air was below 0 °F. 250 litres were worked in all.
Mga materyales para sa hakbang na ito:
Gasolina250 litroMga kailangang kasangkapan:
Prasko ng Salamin sa Distilasyon2
2
Distil through a condenser in a freezing mixture
Distil through a condenser in a freezing mixture
Distil from a flask through a Warren condenser filled with a freezing mixture, and keep every receiver very cold to avoid loss. The paper does not give the mixture. Ours: crushed ice and salt.
Mga kailangang kasangkapan:
Prasko ng Salamin sa Distilasyon
Kondenser na Pang-reflux
Dinurog na yelo
Asin
Termometrong Panlaboratoryo3
3
Let the lightest portions boil from room heat
Let the lightest portions boil from room heat
The portions from -20 to -10 °C boil from the heat of the surrounding air alone. Regulate them by cooling the still, not by heating it.
Mga kailangang kasangkapan:
Prasko ng Salamin sa DistilasyonDinurog na yeloAsinTermometrong Panlaboratoryo4
4
Redistil everything below 12 °C twenty times
Redistil everything below 12 °C twenty times
Collect in single-degree fractions and distil the portions below 12 °C again, twenty times over. By the twentieth run almost nothing stays between 5 and 20 °C, and the butane gathers between -2 and 2 °C.
Mga kailangang kasangkapan:
Prasko ng Salamin sa DistilasyonKondenser na Pang-refluxDinurog na yeloAsinTermometrong Panlaboratoryo5
5
Keep the -2 to 2 °C cut
Keep the -2 to 2 °C cut
This is the butane: 300 grams in Mabery & Hudson's run, specific gravity 0.6029 at 0 °C. It boils at about 0 °C, so it must be kept cold or under pressure. Ours: condense it into a pressure gas cylinder.
Mga kailangang kasangkapan:
Tangke ng gas na may presyonTermometrong PanlaboratoryoAng blueprint na ito ay gumagawa ng
Kaugnay na Blueprint
Ang mga blueprint na ito ay nagbabahagi ng kaalaman — mga teknik, materyales, o prinsipyo
CC0 Pampublikong Domain
Ang blueprint na ito ay inilabas sa ilalim ng CC0. Malaya kang kumopya, magbago, mamahagi, at gumamit nang walang pahintulot.
Suportahan ang Maker sa pamamagitan ng pagbili ng mga produkto sa kanilang Blueprint Komisyon ng Maker itinakda ng mga Vendor, o lumikha ng bagong bersyon ng Blueprint na ito at isama bilang koneksyon sa iyong Blueprint upang ibahagi ang kita.