UBUHANZI
UBWIZA N'UBUZIMA
UBUKORIKORI
UMUCO N'AMATEKA
IMYIDAGADURO
IBIDUKIKIJE
IBIRIBWA N'IBINYOBWA
UBWUBATSI BUSUBIRA INYUMA
UBUMENYI
SIPORO
IKORANABUHANGA
IBYAMBARWA
The Ring Head and the Recording Gap
Volt

Yaremwe na

Volt

30. Kanama 2026SE
1
0
0
0
0

The Ring Head and the Recording Gap

Poulsen recorded on magnetised steel wire in 1898, running the wire past the pole of an electromagnet. It worked and it was crude: the pole's field spread along the wire, so every mark it wrote was long. Eduard Schüller at AEG patented the fix in 1933 and it is still in every drive built today. Bend the magnetic circuit into a RING, and cut one narrow non-magnetic slot in it. Almost all the flux now stays inside the high-permeability core, because that is the easy path, except at the slot, where it has to jump. The fringing field that bulges out of that slot is intense, and it is confined to roughly the slot's own width. The gap does not conduct the flux; it is the one place the flux is forced out into the world, and that is the entire trick. The same ring reads. A magnetised medium moving past the gap pushes flux through the core, and a coil around the core sees a voltage. So the gap length decides both halves at once: the shortest mark you can write, and the shortest wavelength you can read. When the recorded wavelength equals the gap length, the gap averages over exactly one full cycle and the output goes to zero. Every advance in magnetic storage since is, in large part, that slot getting narrower and the medium getting closer. This blueprint is fully buildable: wind a coil on a pair of ferrite U-cores, set the gap with a foil shim, and measure both the 6 dB per octave rise and the cliff it falls off.
Hagati
4 hours

Amabwiriza

1

Wind the head and set the gap

Use a pair of ferrite U-cores: two halves that close into a rectangular ring, with mating faces already ground flat. Real ring heads are built the same way, from two halves, and it gives you two joints. One becomes the gap; the other must close as tightly as you can make it. (A ferrite toroid has no joint to open, and ferrite is too hard to cut cleanly without a diamond saw.) Wind 200 turns of 0.2 mm enamelled wire on one leg and scrape the enamel off the two ends. Close the halves with no shim and measure the inductance on the LCR meter; measure again once the gap is in. Ferrite is so permeable that even a few micrometres of non-magnetic gap in series with it lowers the inductance clearly, and that drop is your first proof the gap is there. Put the shim in ONE joint only, the one the tape will run over. It must be non-magnetic. Household aluminium foil is about 16 micrometres thick; measure yours with the micrometer, and stack layers for a wider gap. Never use a steel feeler gauge or a razor blade: steel is magnetic and would bridge the very gap it is meant to create. Close the other joint face to face with nothing between, and clamp or glue the halves so the faces stay parallel. The tape runs across the outside of the gapped leg. Smooth that face with 600-grit wet paper on a sheet of glass so the medium can pass within a hair of it. Spacing costs more than anything else you can get wrong here, and the notebook shows how much.

Ibikoresho by'iyi ntambwe:

Imitima ibiri ya ferite ifite ishusho ya UImitima ibiri ya ferite ifite ishusho ya U1 igice
Insinga y'Umuringa Yasizwe EnameliInsinga y'Umuringa Yasizwe Enameli10 metero
Urupapuro rwa AluminiyumuUrupapuro rwa Aluminiyumu1 urupapuro

Ibikoresho bikenewe:

MikorometeroMikorometero
Ipima LCR - rya dijitaliIpima LCR - rya dijitali
Ikusanyirizo ry'urupapuro rwo kunozaIkusanyirizo ry'urupapuro rwo kunoza
Ikigereranyo cya Digitale cy'Amasentimetero 6Ikigereranyo cya Digitale cy'Amasentimetero 6
2

Build the read amplifier

A head winding delivers microvolts, so the first stage sets the noise floor and nothing after it can recover what that stage throws away. Bring the two leads to the amplifier as a twisted pair and amplify only their DIFFERENCE: U1A, an OPA1612 wired as a difference amplifier with a gain of 100. Hum from the motor arrives on both leads alike and cancels. In ngspice, 100 mV of 50 Hz hum on both leads left 1 mV at the output, with one of the four resistors deliberately 1 % off. A single-ended stage would have amplified the same hum 100 times and clipped. C_EQ and C_EQ2, 220 pF across the two 100k resistors, are the equalisation. Read-back rises 6 dB per octave on its own, so above 7.2 kHz the amplifier falls at the same rate and flattens the top of the band. Leave both out for the sweep in the next step, so the gain is a flat 100 and you measure the head, not the equaliser. The differentiator and comparator after it recover DATA rather than audio. A recorded bit is a flux REVERSAL, which shows up as a peak in the read voltage. U2A differentiates about a 2.43 V reference, so each peak becomes a zero crossing, and U3A, an LM393, turns each crossing into one edge. R_HYS sets its hysteresis window, which has to be right both ways. Simulated with 200 µV read pulses and 20 µV rms of noise: 330k gave one edge per transition in four of five noise runs and one extra edge in the fifth; with almost no hysteresis, 91 edges for 11 transitions; at 150k to 220k the window was too wide and transitions were lost. The edges came 25 to 35 µs after each peak. Power the op-amps from two 9 V batteries as +9 V and −9 V, and the LM393 from +9 V and ground. Its output is open collector, so return R_PU to the supply of whatever logic reads the pulses. The simulation used behavioural op-amp models, not the vendors' models.

Ikireba KiCanvas kirapakirwa...

Ikireba cy'Umwuga cy'Igishushanyo cya PCB

Ibikoresho by'iyi ntambwe:

Umwongerezi w'imikorere ufite urusaku ruke (OPA1612)Umwongerezi w'imikorere ufite urusaku ruke (OPA1612)1 igice
Sirikwi ya amplifikateri y'imikorereSirikwi ya amplifikateri y'imikorere1 igice
Ikusanyirizo ry'Ibirwanya AmashanyaraziIkusanyirizo ry'Ibirwanya Amashanyarazi1 igice
Agafuka k'ibibiko by'amashanyaraziAgafuka k'ibibiko by'amashanyarazi1 igice
Urunigi rwibumbye rwa mugereranya kabiri LM393Urunigi rwibumbye rwa mugereranya kabiri LM3931 igice
9V Li-ion Rechargeable Battery - 350mAh9V Li-ion Rechargeable Battery - 350mAh2 ibice
Igifata bateriIgifata bateri2 ibice

Ibikoresho bikenewe:

Breadboard - ClassicBreadboard - Classic
Ikusanyirizo ry'Insinga zo GuhuzaIkusanyirizo ry'Insinga zo Guhuza
Osilosikopu ya DigitaleOsilosikopu ya Digitale
3

Sweep it and find your own gap

Glue a strip of cassette tape, coated side out, around the rim of a wheel on the geared motor, and hold the head against it on a sprung arm with the gapped face on the tape. Run the motor from the bench supply and measure the rim speed with the optical tachometer: a few tenths of a metre per second is plenty. Record first. Disconnect the amplifier and drive the head winding from the function generator through a 1 k resistor at its full output, one frequency at a time, for at least one turn of the wheel. Then disconnect the generator, reconnect the amplifier with C_EQ and C_EQ2 left out, and read the peak-to-peak amplitude at U1A's output. Step through the frequencies. The wavelength on the tape is the rim speed divided by the frequency. The output climbs at 6 dB per octave, peaks, then collapses. At the gap's first null it nearly vanishes: there the wavelength is about equal to the gap, a little longer in practice because the field fringes past the gap's edges. At 0.3 m/s, one layer of foil puts that null near 19 kHz. Cross-check it against the shim you measured. Then repeat one point with a sheet of paper between head and tape. That single measurement is the most important number in this blueprint.

Ibikoresho by'iyi ntambwe:

Kasete y'urukondoKasete y'urukondo1 igice

Ibikoresho bikenewe:

Igikora Imirongo y'AmashanyaraziIgikora Imirongo y'Amashanyarazi
Osilosikopu ya DigitaleOsilosikopu ya Digitale
Igipimo cy'imizunguruko cya dijitaliIgipimo cy'imizunguruko cya dijitali
Moteri ya DC ifite gareMoteri ya DC ifite gare
Isoko ry'Amashanyarazi ryo ku MezaIsoko ry'Amashanyarazi ryo ku Meza
4

Gap loss, spacing loss, and the fit

Gupakira ikaye ya Jupyter…

Ibikoresho bikenewe:

Mudasobwa yo ku MezaMudasobwa yo ku Meza
5

Compendium: the head stores nothing

THE HEAD STORES NOTHING. A ferrite core stores its bit IN itself; the ring head has the same hysteresis loop and stores nothing at all. It is a transducer. Which is why a head is made of the SOFTEST magnetic material available — low coercivity, lets go instantly — and the medium of the hardest. Same physics, opposite ends. THE GAP IS A SPACER, NOT A HOLE. It is filled with glass or a hard non-magnetic alloy. It has to survive years of contact without the edges rounding over, because a rounded edge is a wider gap and a wider gap is a lower ceiling. IF IT DOES NOT WORK. No output: the gapped joint is not the one under the tape, or the other joint is not closed, so a second gap is wasting the winding's drive; butt it face to face. Output that does not change when you lift the head off the tape is not playback: it is hum or the motor's field reaching the winding, so twist the leads, move the motor away and screen the head. Double pulses per transition: too little comparator hysteresis. Missing pulses: too much.

Ibikoresho

11

Ibikoresho bikenewe

12
Igiteranyo Giteganyijwe
Ibyo uwabikoze yaguze. Ibikoresho bidafite igiciro ubigura aho ubibonye.
$11.28

CC0 Umurenge rusange

Iyi blueprint yasohowe munsi ya CC0. Ushobora gukoporora, guhindura, gukwirakwiza no gukoresha nta kwemererwa.

Shyigikira Umuremyi ugura ibicuruzwa binyuze muri Blueprint ye Komisiyo y'Umuremyi byashyizweho n'Abacuruzi, cyangwa kora verisiyo nshya y'iyi Blueprint ukayinjiza nk'isano muri Blueprint yawe kugira ngo musangire inyungu.

Ibiganiro

(0)

Injira kugira ngo ujye mu biganiro

Gutegura ibitekerezo...