التعاون
فنون
الجمال والعناية
حِرَف
الثقافة والتاريخ
ترفيه
البيئة
الطعام والمشروبات
الهندسة العكسية
العلوم
رياضة
التقنية
الأجهزة القابلة للارتداء

Glass Saw: Rigid Diamond Wire Ring Driven by Its Rim
Jesse Cogswell's ring saw (US 4,576,139, 1986) for glass, ceramics and stone. The blade is a rigid circle of wire coated with bonded diamond, standing upright through a cutting table. A rubber-tyred wheel on the motor drives it by friction round its own rim at 3000 ft/min or more, and twelve guide wheels on slots round an aluminium back-plate hold it true. Because it cuts with any part of its rim, the work can be turned freely for curves and inside shapes; a sponge in a water tray wets the wire.
The patent sizes the ring from the thickest work to be cut (8 in ring for 3/16 in); the notebook does the sums. The picture: the patent's Fig. 1.
متقدم
3 days
التعليمات
1
1
Cut and brace the back-plate
Cut and brace the back-plate
Cut the back-plate (2A) from aluminium plate, its upper part curved as an arc to shield the saw, stiffened by an angle (2B) along the top and a flat splatter strip (2C) at the front. Bolt on two front struts (21, 21A) and two side struts (22) and bolt them to the base. Ours: drill press.
المواد لهذه الخطوة:
لوح ألمنيوم1 قطعة
زاوية ألومنيوم1 قطعة
برغي سدّاسي الرأس - رتبة 8.81 قطعةالأدوات المطلوبة:
مثقاب عمودي
مفتاح إنجليزي2
2
Cut the wheel-slider apertures
Cut the wheel-slider apertures
Cut slots (32) through the back-plate's arc at 0, 30, 60, 90, 120, 210, 240, 270, 300 and 330° round the ring's centre: two slots at 90° and 210° for the guide pairs, one at each of the others. The slots let each guide wheel slide to the ring.
الأدوات المطلوبة:
مثقاب عمودي3
3
Assemble the guide wheels
Assemble the guide wheels
For each of the twelve guide wheels, stretch two rubber O-rings (27) into the grooves of a bearing wheel (26) with sealed roller bearings, and mount it on a shoulder bolt (28) with a washer, lockwasher and nut.
المواد لهذه الخطوة:
بكرة توجيه12 قطع
حلقة مانعة للتسرب دائرية المقطع24 قطع
برغي كتفي12 قطع
حلقة تثبيت مسطحة12 قطع
Spring Washer12 قطع
صامولة سداسية12 قطعالأدوات المطلوبة:
مفتاح إنجليزي4
4
Turn the drive wheel
Turn the drive wheel
Turn an aluminium disk with a hub, a bored axle hole and a deep groove round its rim, and seat a large rubber O-ring (23) in the groove as its driving tyre. Ours: lathe.
المواد لهذه الخطوة:
لوح ألمنيوم1 قطعة
حلقة مانعة للتسرب دائرية المقطع1 قطعةالأدوات المطلوبة:
مخرطة معادن5
5
Mount the motor and drive axle
Mount the motor and drive axle
Strap the electric motor (51) onto its pillow block (50) with fastening bands (52) and bolt the block to the base. Fix the drive wheel on the motor's axle (24) and carry the axle's end in an axle pillow block (24A, 24B).
المواد لهذه الخطوة:
محرك كهربائي1 قطعة
حزام تثبيت المحرك2 قطع
كتلة محمل2 قطع
عمود فولاذي1 قطعة
برغي سدّاسي الرأس - رتبة 8.81 قطعةالأدوات المطلوبة:
مفتاح إنجليزي6
6
Fit the ring and its guides
Fit the ring and its guides
Stand the ring saw on the drive wheel's tyre. Bolt the guide wheels through their slots: each pair with a tension spring between its two wheels, each single with a spring to the back-plate's lower rim, the one at 330° pressing the ring onto the drive wheel. Set them against the ring, then tighten the nuts. Fit two horizontal roller-guides (17) at 150°, sprung together, just before the cut.
المواد لهذه الخطوة:
شفرة منشار حلقية ماسية1 قطعة
نابض شد11 قطع
بكرة توجيه2 قطعالأدوات المطلوبة:
مفتاح إنجليزي7
7
Fit the table, tray and sponge
Fit the table, tray and sponge
Bolt the water tray (46) on four bracket supports (19, 20) by its four studs; put a ring-shaped sponge (47) in it and the cutting table (44) over it, the ring passing through centre holes reached by slots offset half an inch from a radius. Set the table top below the ring's centre line by the thickest work you will cut. Add water to the tray.
المواد لهذه الخطوة:
صينية1 قطعة
إسفنجة1 قطعة
لوح ألمنيوم1 قطعة
ماء1 batchالأدوات المطلوبة:
مفتاح إنجليزي8
8
Fit the face shield and drip pan
Fit the face shield and drip pan
Bolt the shield arm (41) to the back-plate and pivot a clear acrylic face shield (43) in its holder (42) on a locking screw. The base is a catchment for the coolant with a drain hole in one corner.
المواد لهذه الخطوة:
لوح أكريليك1 قطعة
لوح ألمنيوم1 قطعة
صينية تقطير1 قطعةالأدوات المطلوبة:
مفتاح إنجليزي9
9
Ring size and drive speed
Ring size and drive speed
جارٍ تحميل دفتر Jupyter…
المواد
20- 1 قطعةعنصر نائب
- 1 قطعةعنصر نائب
- عنصر نائب
- 12 قطععنصر نائب
- عنصر نائب
- 12 قطععنصر نائب
- 12 قطععنصر نائب
- 12 قطععنصر نائب
- 12 قطععنصر نائب
- 1 قطعةعنصر نائب
- 2 قطععنصر نائب
- 2 قطععنصر نائب
- 1 قطعةعنصر نائب
- 1 قطعةعنصر نائب
- 11 قطععنصر نائب
- 1 قطعةعنصر نائب
- 1 قطعةعنصر نائب
- 1 batchعنصر نائب
- 1 قطعةعنصر نائب
- 1 قطعةعنصر نائب
هذا المخطط يصنع
CC0 ملكية عامة
هذا المخطط مُصدر بموجب CC0. يحق لك نسخه وتعديله وتوزيعه واستخدامه لأي غرض، دون طلب إذن.
ادعم الصانع بشراء منتجات عبر مخططه حيث يكسب عمولة الصانع يحددها البائعون، أو أنشئ نسخة جديدة من هذا المخطط وضمّنه كرابط في مخططك لمشاركة الإيرادات.
