SANAT
GÜZELLİK & SAĞLIK
ZANAAT
KÜLTÜR & TARİH
EĞLENCE
ÇEVRE
YİYECEK & İÇECEK
TERS MÜHENDİSLİK
BİLİMLER
SPOR
TEKNOLOJİ
GİYİLEBİLİR ÜRÜNLER
Ball Bearings: Races, Balls and Cage
Emma

Oluşturan

Emma

11. Ekim 2026SE
23
0
0
0
0

Ball Bearings: Races, Balls and Cage

A ball bearing has four parts: an outer race, an inner race, the balls that roll between them, and a cage that keeps the balls evenly spaced. Almost all of it is steel, usually 52100 (1.5% chromium, 1% carbon), which can be made very hard and tough by heat treating; 440C stainless is used where rust is a problem. The races are turned from tubing, the balls are cold headed from thick wire, both are hardened, tempered, ground and lapped to an almost mirror finish, and the cage is stamped from thin sheet. Even an inexpensive bearing's balls may be out of round by no more than 25 millionths of an inch; precision bearings allow five millionths.
İleri
Factory process

Talimatlar

1

Turn the races

Cut the basic shape of both races from steel tubing on automatic lathe-like machines, leaving every dimension slightly oversize: the steel usually warps in heat treatment.

Bu adım için malzemeler:

Rulman çeliği boru (52100)Rulman çeliği boru (52100)1 as required

Gerekli aletler:

Otomatik tornaOtomatik torna
2

Harden and temper the races

Heat to about 843 °C (1,550 °F) for up to several hours depending on size, then quench in oil: hard but brittle. Temper at about 149 °C (300 °F) and let cool in air: hard and tough.

Gerekli aletler:

Yağda su vermeli sürekli sertleştirme fırınıYağda su vermeli sürekli sertleştirme fırını
Menevişleme fırınıMenevişleme fırını
3

Grind and lap the races

The hardened steel is too hard to cut, so grind almost every surface: the fitting surfaces round, the sides flat. Grind the ball track, then lap it for several hours with a very fine abrasive slurry to an almost mirror finish.

Gerekli aletler:

Rulman bileziği taşlama makinesiRulman bileziği taşlama makinesi
Bilye yolu lepleme makinesiBilye yolu lepleme makinesi
Lepleme macunuLepleme macunu
4

Cold head the balls

Feed thick wire from a roll into a machine that cuts off a short piece and smashes both ends in toward the middle between two dies, without heating. The ball comes out with a ring of "flash" round its middle.

Bu adım için malzemeler:

Rulman çeliği tel (52100)Rulman çeliği tel (52100)1 as required

Gerekli aletler:

Soğuk dövme makinesiSoğuk dövme makinesi
5

Remove the flash

Run the balls many times round rough grooves between two cast-iron discs, one turning and one fixed, until the flash is gone and they are nearly round. Leave about 0.008 in (0.2 mm) for finishing.

Gerekli aletler:

Bilye çapak alma makinesiBilye çapak alma makinesi
6

Harden, grind and lap the balls

Heat treat and temper the balls like the races. Grind them in the same kind of disc machine with grinding wheels to within a few ten-thousandths of an inch, then lap them 8–10 hours on cast-iron wheels with lapping compound.

Gerekli aletler:

Yağda su vermeli sürekli sertleştirme fırınıYağda su vermeli sürekli sertleştirme fırını
Menevişleme fırınıMenevişleme fırını
Bilye taşlama makinesiBilye taşlama makinesi
Bilye lepleme makinesiBilye lepleme makinesi
Lepleme macunuLepleme macunu
7

Stamp the cage

Stamp the cage halves from thin steel sheet and bend them to shape in a die. (Plastic cages are injection moulded instead.)

Bu adım için malzemeler:

Çelik sacÇelik sac1 as required

Gerekli aletler:

Sac presiSac presi
8

Assemble

Put the inner race inside the outer race, pushed as far to one side as it goes, and drop the balls into the gap opposite. Centre the races and spread the balls evenly, fit the cage (steel cages riveted, plastic ones snapped in) and coat the bearing with a thin film of petroleum jelly against rust.

Bu adım için malzemeler:

Çelik perçinlerÇelik perçinler1 as required
VazelinVazelin1 as required

Malzemeler

5

Gerekli Aletler

11

CC0 Kamu Malı

Bu plan CC0 lisansıyla yayınlanmıştır. İzin almadan kopyalayabilir, değiştirebilir, dağıtabilir ve herhangi bir amaçla kullanabilirsiniz.

Planı üzerinden ürün satın alarak Maker'ı destekleyin, böylece Maker Komisyonu Satıcılar tarafından belirlenen komisyonu kazanırlar veya bu Planın yeni bir versiyonunu oluşturun ve gelir paylaşımı için kendi Planınıza bağlantı olarak ekleyin.

Tartışma

(0)

Giriş yapın tartışmaya katılmak için

Yorumlar yükleniyor...