МИСТЕЦТВО
КРАСА ТА ЗДОРОВ'Я
РЕМЕСЛО
КУЛЬТУРА ТА ІСТОРІЯ
РОЗВАГИ
СЕРЕДОВИЩЕ
ЇЖА ТА НАПІЇ
ЗБОРНА ІНЖЕНЕРІЯ
НАУК
СПОРТ
ТЕХНОЛОГІЯ
НОСИМО
High-Pressure Polyethylene
Karen

Створено

Karen

22. вересень 2026SE
1
0
0
0
0

High-Pressure Polyethylene

In March 1933 Eric Fawcett and Reginald Gibson at ICI squeezed ethylene gas with benzaldehyde to about 1400 atmospheres and found a white waxy solid in the vessel. It could not be repeated reliably until 1935, when Michael Perrin's team traced the trick to a trace of oxygen that started the chains. The product was polyethylene - light, tough, a superb electrical insulator, and soon the cable insulation of wartime radar. **US 2,153,553**, "Polymerization of olefins", Fawcett, Gibson and Perrin, assigned to Imperial Chemical Industries, granted 11. April 1939, claims "subjecting ethylene to a pressure above about 500 atmospheres and a temperature above about 100 C"; its example runs at 2000 atmospheres and 170 °C. **Nobody reproduces 2000 atmospheres at home.** You work the polymer instead: fuse polyethylene bags into a tough sheet with an iron, then measure its density to tell high-pressure (branched, low-density) polyethylene from its later straight-chain sibling.
Початківець
90 minutes

Інструкції

1

Sort the bags

Collect clean, dry carrier or produce bags marked LDPE (recycling code 4). Cut off handles and seams; open each into a flat sheet.

Матеріали для цього кроку:

Поліетиленові пакетиПоліетиленові пакети8 штук

Необхідні інструменти ({count})

НожиціНожиці
2

Stack between parchment

Stack 6 layers of bag film, printed side inward, between two sheets of baking parchment. The film must never touch the iron.

Матеріали для цього кроку:

Пергаментний папір для випіканняПергаментний папір для випікання2 аркушів
3

Fuse with the iron

Iron on a low-medium setting, no steam, moving constantly for 15 seconds. Ventilate. Too hot and it shrivels and smokes - lower the setting.

Необхідні інструменти ({count})

Парова праскаПарова праска
Респіратор N95Респіратор N95
4

Flip, repeat, cool

Flip and iron the other side. Peel the parchment once cool. Re-iron any bubbled patches. The layers are now one welded sheet.

Необхідні інструменти ({count})

Парова праскаПарова праска
5

Pull-test both

Cut 20 mm strips from the fused sheet and from a single bag layer. Clamp each in the vise and pull with the spring scale. Record the peak force.

Необхідні інструменти ({count})

Динамометр (пружинні ваги)Динамометр (пружинні ваги)
Слюсарні лещатаСлюсарні лещата
НожиціНожиці
6

Float test

Pour 50 ml isopropyl alcohol into a beaker. Drop in a small chip of the sheet - it sinks. Add water 10 ml at a time, stirring, then 1 ml at a time once the chip starts to lift, until it hangs mid-liquid. Note the total water added.

Матеріали для цього кроку:

Ізопропіловий спирт 99 %Ізопропіловий спирт 99 %50 мл

Необхідні інструменти ({count})

Скляна хімічна склянкаСкляна хімічна склянка
Мірний циліндрМірний циліндр
Набір піпеток і крапельницьНабір піпеток і крапельниць
Паличка для перемішуванняПаличка для перемішування
7

Pressure, density, siblings

Завантаження блокнота Jupyter…
8

History & Context

**What the patent specifies:** ethylene above about 500 atm and 100 °C (preferred 1000+ atm, 150–250 °C). **Modern build (derived):** post-consumer LDPE film, fused well below its decomposition temperature. Low-pressure routes in the 1950s gave straight-chain, denser HDPE; both are still made in huge volumes because the branches that make LDPE weaker also make it softer and clearer. Limits: it creeps under load, softens around 100 °C, and burns.

Матеріали

3

Необхідні інструменти

9

Пов'язані креслення

Ці креслення діляться знаннями — техніки, матеріали або принципи

CC0 Суспільне надбання

Це креслення випущено під ліцензією CC0. Ви можете вільно копіювати, змінювати, поширювати та використовувати цю роботу для будь-яких цілей без запиту дозволу.

Підтримайте мейкера, купуючи продукти через його креслення, де він отримує Комісію мейкера встановлену вендорами, або створіть нову ітерацію цього креслення та включіть його як зв'язок у власне креслення для розподілу доходу.

Обговорення

(0)

Увійти щоб приєднатися до обговорення

Завантаження коментарів...