KUNST
SCHÖNHEIT & WELLNESS
HANDWERK
KULTUR & GESCHICHTE
UNTERHALTUNG
UMFELD
ESSEN & GETRÄNKE
REVERSE ENGINEERING
WISSENSCHAFTEN
SPORT
TECHNOLOGIE
WEARABLES
Ball Bearings: Races, Balls and Cage
Emma

Erstellt von

Emma

11. Oktober 2026SE
21
0
0
0
0

Ball Bearings: Races, Balls and Cage

A ball bearing has four parts: an outer race, an inner race, the balls that roll between them, and a cage that keeps the balls evenly spaced. Almost all of it is steel, usually 52100 (1.5% chromium, 1% carbon), which can be made very hard and tough by heat treating; 440C stainless is used where rust is a problem. The races are turned from tubing, the balls are cold headed from thick wire, both are hardened, tempered, ground and lapped to an almost mirror finish, and the cage is stamped from thin sheet. Even an inexpensive bearing's balls may be out of round by no more than 25 millionths of an inch; precision bearings allow five millionths.
Erfahren
Factory process

Anweisungen

1

Turn the races

Cut the basic shape of both races from steel tubing on automatic lathe-like machines, leaving every dimension slightly oversize: the steel usually warps in heat treatment.

Materialien für diesen Schritt:

Wälzlagerstahlrohr (52100)Wälzlagerstahlrohr (52100)1 as required

Benötigte Werkzeuge:

DrehautomatDrehautomat
2

Harden and temper the races

Heat to about 843 °C (1,550 °F) for up to several hours depending on size, then quench in oil: hard but brittle. Temper at about 149 °C (300 °F) and let cool in air: hard and tough.

Benötigte Werkzeuge:

Durchlauf-Härteofen mit ÖlabschreckungDurchlauf-Härteofen mit Ölabschreckung
AnlassofenAnlassofen
3

Grind and lap the races

The hardened steel is too hard to cut, so grind almost every surface: the fitting surfaces round, the sides flat. Grind the ball track, then lap it for several hours with a very fine abrasive slurry to an almost mirror finish.

Benötigte Werkzeuge:

Lagerring-SchleifmaschineLagerring-Schleifmaschine
Laufbahn-LäppmaschineLaufbahn-Läppmaschine
LäppmittelLäppmittel
4

Cold head the balls

Feed thick wire from a roll into a machine that cuts off a short piece and smashes both ends in toward the middle between two dies, without heating. The ball comes out with a ring of "flash" round its middle.

Materialien für diesen Schritt:

Wälzlagerstahldraht (52100)Wälzlagerstahldraht (52100)1 as required

Benötigte Werkzeuge:

KaltstauchmaschineKaltstauchmaschine
5

Remove the flash

Run the balls many times round rough grooves between two cast-iron discs, one turning and one fixed, until the flash is gone and they are nearly round. Leave about 0.008 in (0.2 mm) for finishing.

Benötigte Werkzeuge:

Kugel-EntgratmaschineKugel-Entgratmaschine
6

Harden, grind and lap the balls

Heat treat and temper the balls like the races. Grind them in the same kind of disc machine with grinding wheels to within a few ten-thousandths of an inch, then lap them 8–10 hours on cast-iron wheels with lapping compound.

Benötigte Werkzeuge:

Durchlauf-Härteofen mit ÖlabschreckungDurchlauf-Härteofen mit Ölabschreckung
AnlassofenAnlassofen
KugelschleifmaschineKugelschleifmaschine
KugelläppmaschineKugelläppmaschine
LäppmittelLäppmittel
7

Stamp the cage

Stamp the cage halves from thin steel sheet and bend them to shape in a die. (Plastic cages are injection moulded instead.)

Materialien für diesen Schritt:

StahlblechStahlblech1 as required

Benötigte Werkzeuge:

StanzpresseStanzpresse
8

Assemble

Put the inner race inside the outer race, pushed as far to one side as it goes, and drop the balls into the gap opposite. Centre the races and spread the balls evenly, fit the cage (steel cages riveted, plastic ones snapped in) and coat the bearing with a thin film of petroleum jelly against rust.

Materialien für diesen Schritt:

StahlnietenStahlnieten1 as required
VaselineVaseline1 as required

Materialien

5

Benötigte Werkzeuge

11

CC0 Gemeinfrei

Dieser Blueprint ist unter CC0 veröffentlicht. Sie dürfen dieses Werk für jeden Zweck frei kopieren, ändern, verbreiten und verwenden, ohne um Erlaubnis zu fragen.

Unterstützen Sie den Maker, indem Sie Produkte über seinen Blueprint kaufen, wo er eine Maker-Provision von Anbietern festgelegt, verdient. Oder erstellen Sie eine neue Iteration dieses Blueprints und verbinden Sie ihn in Ihrem eigenen Blueprint, um Einnahmen zu teilen.

Diskussion

(0)

Anmelden um an der Diskussion teilzunehmen

Kommentare werden geladen...