Samvinna
LIST
FEGURÐ OG VELLÍÐAN
HANDVERK
MENNING OG SAGA
SKEMMTUN
UMHVERFI
MATUR OG DRYKKUR
ÖFUGVERKFRÆÐI
VÍSINDI
ÍÞRÓTTIR
TÆKNI
KLÆÐANLEG TÆKNI
Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)
Ed

Búin til af

Ed

2. nóvember 2026FI
13
0
0
0
0

Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)

A six-inch caliper that reads out on a display. Under the slide, a strip of etched copper bars runs along the beam. Electrodes on the slider pass a signal through the bars by capacitance, and the slider's electronics count the bars crossed and work out the position in between. Result: a digital caliper reading in inches or millimetres, repeatable to a ten-thousandth of an inch, with floating zero, peak hold and high/low limits. It runs on two 1.5 V cells at 10-50 microamps. Source: L. K. Baxter and R. J. Buehler (L. S. Starrett Co.), US Patent 4,586,260 (1986). Unknown: the metal of the beam, slide and rod, their dimensions, the processor's program, and how the chips and display are made. Ours: the etchant, photoresist and glue. Picture: Wikimedia Commons.
Lengra kominn
2 days

Leiðbeiningar

1

Etch the scale

Etch the scale pattern onto a strip of copper-clad epoxy fibreglass with photoresist and etchant. Each copper bar is 0.40 inch long, with a wider centre 0.12 inch long and two ends 0.14 inch long. Space the bars on 0.05 inch centres: the centres sit 0.004 inch apart, the ends 0.025 inch apart. Run the pattern the full length of the scale. Ours: dry film resist and ferric chloride.

Efni fyrir þetta skref:

Óáletruð prentplata (koparhúðuð)Óáletruð prentplata (koparhúðuð)1 strip, length of the beam

Nauðsynleg verkfæri:

Þurrfilmu-ljósþolÞurrfilmu-ljósþol
JárnklóríðlausnJárnklóríðlausn
Efnaþolnir hanskarEfnaþolnir hanskar
2

Fix the scale into the beam

The beam is a metal bar with the fixed outside and inside jaws at one end, a wide shallow channel in its face and a second channel along its back. Fix the scale permanently into the face channel, copper up. The patent allows etching before or after this step. Not given: the metal, the dimensions and how the scale is fixed. Ours: epoxy.

Efni fyrir þetta skref:

RennimálsstöngRennimálsstöng1 with integral jaws
Tveggja þátta epoxýTveggja þátta epoxý1 a little

Nauðsynleg verkfæri:

Óþekkt málÓþekkt mál
3

Fit the parts to the circuit

The circuit is one folded piece: a double-sided slider board joined by a flexible hinge to a circuit board. Its bottom face has two pickup electrodes, 0.750 x 0.110 inch and 0.0625 inch apart. On each side of them is an interdigitated transmitter array: fingers 0.115 inch long on 0.025 inch spacing, opening to 0.0375 inch at the centre. On the circuit board, solder or wire-bond the two chips: an NEC uPD7503 3 V processor (768 bits RAM, 2 kB ROM) and a CMOS gate array. Then fit the LCD, the 100 kHz crystal, the integrating capacitor and the MODE and SET buttons. Not given: the processor's program. Ours: a capacitor from a kit.

Efni fyrir þetta skref:

Stíf-sveigjanleg rafrásaplataStíf-sveigjanleg rafrásaplata1 slider board + circuit board
SamrásSamrás2 uPD7503 CPU, CMOS gate array
LCD-skjár með hlutumLCD-skjár með hlutum1 5 digits
KvarskristallKvarskristall1 100 kHz
ÞéttasettÞéttasett1 one integrating capacitor
ÞrýstihnappurÞrýstihnappur2 MODE, SET
LóðtinsvírLóðtinsvír1 a little

Nauðsynleg verkfæri:

LóðboltiLóðbolti
4

Build the slide

The slide frame wraps the back and edges of the beam and carries the movable jaws. Fix it to the depth rod, which runs in the back channel of the beam; the rod's free end is the depth gauge. Put the moulded plastic housing between the frame ends. Fasten two metal wear strips under the slider board, one on each side of the scale. They ride on the beam and connect the board's copper to it. Not given: the metal and sizes.

Efni fyrir þetta skref:

SleðagrindSleðagrind1 with jaws
Óþekktur málmurÓþekktur málmur1 depth rod and two wear strips
SleðahúsSleðahús1 stykki

Nauðsynleg verkfæri:

Óþekkt málÓþekkt mál
NákvæmnisskrúfjárnasettNákvæmnisskrúfjárnasett
5

Assemble and check

Fold the circuit into the housing recess, slider board facing the scale, and screw it to the frame. The electrodes must lie parallel to the scale bars at every point of travel. Put the two 1.5 V cells (the patent says 'zinc oxide') in the battery pockets of the circuit. The display shows five digits, a ten-thousandths bar graph, a minus sign and 'mm', plus PEAK, LOW, HIGH and LIMIT. Ours: check the reading against a vernier caliper.

Efni fyrir þetta skref:

VélskrúfurVélskrúfur2 stykki
1,5 V hnapparafhlaða1,5 V hnapparafhlaða2 stykki

Nauðsynleg verkfæri:

NákvæmnisskrúfjárnasettNákvæmnisskrúfjárnasett
SkífmælirSkífmælir

Efni

15

Nauðsynleg verkfæri

7

CC0 opinbert ríki

Þessi teikning er gefin út undir CC0. Þér er frjálst að afrita, breyta, dreifa og nota þetta verk í hvaða tilgangi sem er, án þess að biðja um leyfi.

Studdu smiðinn með því að kaupa vörur í gegnum teikningu hans þar sem hann fær þóknun smiða sem seljendur ákvarða, eða búðu til nýja endurskoðun á þessari teikningu og tengdu hana sem tengingu í þinni eigin teikningu til að deila tekjum.

Umræða

(0)

Skrá inn til að taka þátt í umræðunni

Hleður athugasemdum...