ARTE
BELLEZZA E BENESSERE
MESTIERE
CULTURA E STORIA
DIVERTIMENTO
AMBIENTE
CIBO E BEVANDE
INGEGNERIA INVERSA
SCIENZE
SPORT
TECNOLOGIA
INDOSSABILI
Binding a Besom Broom — The Birch-Twig Broom on a Hazel Handle
YourGrandma

Creato da

YourGrandma

2. luglio 2026IS
39
0
0
0
0

Binding a Besom Broom — The Birch-Twig Broom on a Hazel Handle

The besom is the oldest broom: a fat bundle of springy birch twigs bound around a hazel or ash handle. Every household swept with one, and it cost nothing but a walk to the woods. There are no nails and no glue — the head is held by tight withy bindings and a single wooden peg, and it only grips harder as the birch dries and shrinks. This blueprint binds a besom from cut brush to finished broom using hand tools alone.
Principiante
3

Istruzioni

1

Cut the birch brush

Cut generous bundles of thin, whippy birch twigs — the 'brush'. Winter-cut birch, taken when the tree is bare, is springiest and lasts longest. Keep the twigs long and unbroken.

Materiali per questo passaggio:

Spazzola di betullaSpazzola di betulla1 fascio

Strumenti necessari:

RoncolaRoncola
2

Wilt the twigs supple

Lay the cut brush somewhere cool for a few days until the twigs lose their brittleness and bend without snapping. Supple twigs pack tightly and bind without cracking.

Materiali per questo passaggio:

Spazzola di betullaSpazzola di betulla1 fascio
3

Cut and point the handle

Cut a straight length of hazel or ash about a thumb-and-a-half thick for the handle. Trim it clean and whittle one end to a long blunt point so the brush seats around it.

Materiali per questo passaggio:

Pertiche di legno verdePertiche di legno verde1 pezzo

Strumenti necessari:

RoncolaRoncola
ColtelloColtello
4

Soak the binding withies

Soak split willow withies in water until they are fully flexible. These flexible ties will cinch the brush to the handle; they must bend sharply without breaking.

Materiali per questo passaggio:

Vimine di saliceVimine di salice2 pezzi
AcquaAcqua5 litri
5

Lay the brush around the handle

Stand the pointed handle upright and lay birch twigs evenly all the way around it, butt ends up along the handle and tips hanging down. Keep the bundle even so the finished broom is not lopsided.

Materiali per questo passaggio:

Spazzola di betullaSpazzola di betulla1 fascio
6

Bind the top band

Squeeze the twigs tight against the handle and wind a soaked withy hard around the bundle near the top of the brush. Pull it as tight as you can and twist and tuck the ends to lock the band.

Materiali per questo passaggio:

Vimine di saliceVimine di salice1 pezzo
7

Bind the second band

Wind a second withy band about a hand's width below the first and cinch it just as tight. Two bands stop the brush from splaying and spread the sweeping wear.

Materiali per questo passaggio:

Vimine di saliceVimine di salice1 pezzo
8

Peg the head to the handle

Whittle a small hardwood peg. Start a hole through the handle between the bindings with the awl, then drive the peg through with the mallet so the head can never slide off the handle.

Strumenti necessari:

ColtelloColtello
PunteruoloPunteruolo
Mazzuolo di legnoMazzuolo di legno
9

Trim the sweeping end

Trim the hanging tips of the brush level across the bottom with the billhook so the broom meets the floor evenly and sweeps cleanly.

Strumenti necessari:

RoncolaRoncola
10

Season the besom

Stand the finished besom in a dry place to season. As the birch dries it stiffens into a firm brush and the withy bindings shrink even tighter — the broom is ready to sweep.

Materiali

7

Strumenti richiesti

4

Materiali dei progetti collegati

Building a Wattle Fence — Woven Wood Panel Construction
10% Attribuzione

Building a Wattle Fence — Woven Wood Panel Construction

di WoodyNO

Lavorazione del legno

103
0
0
0
2
0

Blueprint correlati

Questi blueprint condividono conoscenze — tecniche, materiali o principi

Egyptian Reed Basket — Weaving a Coiled Reed Basket

Egyptian Reed Basket — Weaving a Coiled Reed Basket

di TexFO

Lavorazione della corda

88
0
0
0
1
0
Building a Wattle-and-Daub Wall — The Universal Prehistoric Construction Technique

Building a Wattle-and-Daub Wall — The Universal Prehistoric Construction Technique

di WoodyNO

Lavorazione del legno

75
0
0
0
0
0

CC0 Pubblico dominio

Questo progetto è rilasciato sotto CC0. Sei libero di copiare, modificare, distribuire e utilizzare quest'opera per qualsiasi scopo, senza chiedere permesso.

Supporta il Maker acquistando prodotti tramite il suo progetto dove guadagna una Commissione Maker stabilita dai venditori, oppure crea una nuova iterazione di questo progetto e includilo come collegamento nel tuo progetto per condividere i ricavi.

Commenti

(0)

Accedi per partecipare alla discussione

Caricamento commenti...