Хамтын ажиллагаа
УРЛАГ
ГОО САЙХАН БА ЭРҮҮЛ МЭНД
ГАРААР ХИЙСЭН
СОЁЛ БА ТҮҮХ
ҮЗВЭР НААДАМ
БАЙГАЛЬ ОРЧИН
ХООЛ БА УНДАА
УРВУУ ИНЖЕНЕРЧЛЭЛ
ШИНЖЛЭХ УХААН
СПОРТ
ТЕХНОЛОГИ
ӨМСДӨГ ХЭРЭГСЭЛ
Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)
Ed

Зохиогч

Ed

2. Арван нэгдүгээр сар 2026FI
13
0
0
0
0

Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)

A six-inch caliper that reads out on a display. Under the slide, a strip of etched copper bars runs along the beam. Electrodes on the slider pass a signal through the bars by capacitance, and the slider's electronics count the bars crossed and work out the position in between. Result: a digital caliper reading in inches or millimetres, repeatable to a ten-thousandth of an inch, with floating zero, peak hold and high/low limits. It runs on two 1.5 V cells at 10-50 microamps. Source: L. K. Baxter and R. J. Buehler (L. S. Starrett Co.), US Patent 4,586,260 (1986). Unknown: the metal of the beam, slide and rod, their dimensions, the processor's program, and how the chips and display are made. Ours: the etchant, photoresist and glue. Picture: Wikimedia Commons.
Дээд шат
2 days

Зааварчилгаа

1

Etch the scale

Etch the scale pattern onto a strip of copper-clad epoxy fibreglass with photoresist and etchant. Each copper bar is 0.40 inch long, with a wider centre 0.12 inch long and two ends 0.14 inch long. Space the bars on 0.05 inch centres: the centres sit 0.004 inch apart, the ends 0.025 inch apart. Run the pattern the full length of the scale. Ours: dry film resist and ferric chloride.

Энэ алхмын материал:

Хоосон хэвлэмэл хэлхээний хавтан (зэс бүрхүүлтэй)Хоосон хэвлэмэл хэлхээний хавтан (зэс бүрхүүлтэй)1 strip, length of the beam

Шаардлагатай багаж:

Хуурай хальсан фоторезистХуурай хальсан фоторезист
Төмрийн гурван хлоридын уусмалТөмрийн гурван хлоридын уусмал
Химид тэсвэртэй бээлийХимид тэсвэртэй бээлий
2

Fix the scale into the beam

The beam is a metal bar with the fixed outside and inside jaws at one end, a wide shallow channel in its face and a second channel along its back. Fix the scale permanently into the face channel, copper up. The patent allows etching before or after this step. Not given: the metal, the dimensions and how the scale is fixed. Ours: epoxy.

Энэ алхмын материал:

Штангенциркулийн штангШтангенциркулийн штанг1 with integral jaws
Хоёр бүрэлдэхүүнт эпоксиХоёр бүрэлдэхүүнт эпокси1 a little

Шаардлагатай багаж:

Тодорхойгүй хэмжээсТодорхойгүй хэмжээс
3

Fit the parts to the circuit

The circuit is one folded piece: a double-sided slider board joined by a flexible hinge to a circuit board. Its bottom face has two pickup electrodes, 0.750 x 0.110 inch and 0.0625 inch apart. On each side of them is an interdigitated transmitter array: fingers 0.115 inch long on 0.025 inch spacing, opening to 0.0375 inch at the centre. On the circuit board, solder or wire-bond the two chips: an NEC uPD7503 3 V processor (768 bits RAM, 2 kB ROM) and a CMOS gate array. Then fit the LCD, the 100 kHz crystal, the integrating capacitor and the MODE and SET buttons. Not given: the processor's program. Ours: a capacitor from a kit.

Энэ алхмын материал:

Хатуу-уян хэлхээний самбарХатуу-уян хэлхээний самбар1 slider board + circuit board
Интеграл схемИнтеграл схем2 uPD7503 CPU, CMOS gate array
Сегмент шингэн болор дэлгэцСегмент шингэн болор дэлгэц1 5 digits
Кварцын болорКварцын болор1 100 kHz
Конденсаторын багцКонденсаторын багц1 one integrating capacitor
ТовчлуурТовчлуур2 MODE, SET
Гагнуурын утасГагнуурын утас1 a little

Шаардлагатай багаж:

Гагнуурын хэрэгсэлГагнуурын хэрэгсэл
4

Build the slide

The slide frame wraps the back and edges of the beam and carries the movable jaws. Fix it to the depth rod, which runs in the back channel of the beam; the rod's free end is the depth gauge. Put the moulded plastic housing between the frame ends. Fasten two metal wear strips under the slider board, one on each side of the scale. They ride on the beam and connect the board's copper to it. Not given: the metal and sizes.

Энэ алхмын материал:

Гулсуурын хүрээГулсуурын хүрээ1 with jaws
Тодорхойгүй металлТодорхойгүй металл1 depth rod and two wear strips
Гулсуурын бүрхүүлГулсуурын бүрхүүл1 ширхэг

Шаардлагатай багаж:

Тодорхойгүй хэмжээсТодорхойгүй хэмжээс
Нарийн халивны багцНарийн халивны багц
5

Assemble and check

Fold the circuit into the housing recess, slider board facing the scale, and screw it to the frame. The electrodes must lie parallel to the scale bars at every point of travel. Put the two 1.5 V cells (the patent says 'zinc oxide') in the battery pockets of the circuit. The display shows five digits, a ten-thousandths bar graph, a minus sign and 'mm', plus PEAK, LOW, HIGH and LIMIT. Ours: check the reading against a vernier caliper.

Энэ алхмын материал:

Машины шурагМашины шураг2 ширхэг
1.5 В товчин зай1.5 В товчин зай2 ширхэг

Шаардлагатай багаж:

Нарийн халивны багцНарийн халивны багц
Верньер штатахуун (штангенциркуль)Верньер штатахуун (штангенциркуль)

Материал

15

Шаардлагатай багаж

7

Холбогдсон загварын материал

Холбоотой загварууд

Эдгээр загварууд мэдлэг хуваалцдаг — арга техник, материал эсвэл зарчим

CC0 Нийтийн домэйн

Энэ загвар CC0 дор гаргагдсан. Та зөвшөөрөл авахгүйгээр хуулах, өөрчлөх, түгээх, ашиглах боломжтой.

Загвараар дамжуулан бүтээгдэхүүн худалдаж авч Бүтээгчийг дэмжээрэй Бүтээгчийн шимтгэл Борлуулагчаар тогтоосон, эсвэл энэ загварын шинэ хувилбар үүсгэж орлогоо хуваахын тулд өөрийн загварт холбоос болгон оруулна уу.

Хэлэлцүүлэг

(0)

Нэвтрэх хэлэлцүүлэгт нэгдэхийн тулд

Сэтгэгдлүүдийг ачаалж байна...