Pakikipagtulungan
SINING
BEAUTY AT WELLNESS
CRAFTS
KULTURA AT KASAYSAYAN
LIBANGAN
KAPALIGIRAN
PAGKAIN AT INUMIN
REVERSE ENGINEERING
AGHAM
ISPORTS
TEKNOLOHIYA
MGA WEARABLE
Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)
Ed

Nilikha ni

Ed

2. Nobyembre 2026FI
9
0
0
0
0

Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)

A six-inch caliper that reads out on a display. Under the slide, a strip of etched copper bars runs along the beam. Electrodes on the slider pass a signal through the bars by capacitance, and the slider's electronics count the bars crossed and work out the position in between. Result: a digital caliper reading in inches or millimetres, repeatable to a ten-thousandth of an inch, with floating zero, peak hold and high/low limits. It runs on two 1.5 V cells at 10-50 microamps. Source: L. K. Baxter and R. J. Buehler (L. S. Starrett Co.), US Patent 4,586,260 (1986). Unknown: the metal of the beam, slide and rod, their dimensions, the processor's program, and how the chips and display are made. Ours: the etchant, photoresist and glue. Picture: Wikimedia Commons.
Abantado
2 days

Mga Tagubilin

1

Etch the scale

Etch the scale pattern onto a strip of copper-clad epoxy fibreglass with photoresist and etchant. Each copper bar is 0.40 inch long, with a wider centre 0.12 inch long and two ends 0.14 inch long. Space the bars on 0.05 inch centres: the centres sit 0.004 inch apart, the ends 0.025 inch apart. Run the pattern the full length of the scale. Ours: dry film resist and ferric chloride.

Mga materyales para sa hakbang na ito:

Blangkong PCB (may tanso)Blangkong PCB (may tanso)1 strip, length of the beam

Mga kailangang kasangkapan:

Tuyong pelikulang photoresistTuyong pelikulang photoresist
Solusyon ng ferric chlorideSolusyon ng ferric chloride
Gwantes na Matibay sa KemikalGwantes na Matibay sa Kemikal
2

Fix the scale into the beam

The beam is a metal bar with the fixed outside and inside jaws at one end, a wide shallow channel in its face and a second channel along its back. Fix the scale permanently into the face channel, copper up. The patent allows etching before or after this step. Not given: the metal, the dimensions and how the scale is fixed. Ours: epoxy.

Mga materyales para sa hakbang na ito:

Baras ng caliperBaras ng caliper1 with integral jaws
Epoksing dalawang bahagiEpoksing dalawang bahagi1 a little

Mga kailangang kasangkapan:

Hindi alam na sukatHindi alam na sukat
3

Fit the parts to the circuit

The circuit is one folded piece: a double-sided slider board joined by a flexible hinge to a circuit board. Its bottom face has two pickup electrodes, 0.750 x 0.110 inch and 0.0625 inch apart. On each side of them is an interdigitated transmitter array: fingers 0.115 inch long on 0.025 inch spacing, opening to 0.0375 inch at the centre. On the circuit board, solder or wire-bond the two chips: an NEC uPD7503 3 V processor (768 bits RAM, 2 kB ROM) and a CMOS gate array. Then fit the LCD, the 100 kHz crystal, the integrating capacitor and the MODE and SET buttons. Not given: the processor's program. Ours: a capacitor from a kit.

Mga materyales para sa hakbang na ito:

Rigid-flex na circuit boardRigid-flex na circuit board1 slider board + circuit board
Integrated circuit (IC)Integrated circuit (IC)2 uPD7503 CPU, CMOS gate array
Segment LCD panelSegment LCD panel1 5 digits
Quartz crystalQuartz crystal1 100 kHz
Kit ng mga KapasitorKit ng mga Kapasitor1 one integrating capacitor
PindutanPindutan2 MODE, SET
Kawad na PanghinangKawad na Panghinang1 a little

Mga kailangang kasangkapan:

PanghinangPanghinang
4

Build the slide

The slide frame wraps the back and edges of the beam and carries the movable jaws. Fix it to the depth rod, which runs in the back channel of the beam; the rod's free end is the depth gauge. Put the moulded plastic housing between the frame ends. Fasten two metal wear strips under the slider board, one on each side of the scale. They ride on the beam and connect the board's copper to it. Not given: the metal and sizes.

Mga materyales para sa hakbang na ito:

Frame ng slideFrame ng slide1 with jaws
Hindi alam na metalHindi alam na metal1 depth rod and two wear strips
Kaha ng slideKaha ng slide1 piraso

Mga kailangang kasangkapan:

Hindi alam na sukatHindi alam na sukat
Set ng tumpak na distornilyadorSet ng tumpak na distornilyador
5

Assemble and check

Fold the circuit into the housing recess, slider board facing the scale, and screw it to the frame. The electrodes must lie parallel to the scale bars at every point of travel. Put the two 1.5 V cells (the patent says 'zinc oxide') in the battery pockets of the circuit. The display shows five digits, a ten-thousandths bar graph, a minus sign and 'mm', plus PEAK, LOW, HIGH and LIMIT. Ours: check the reading against a vernier caliper.

Mga materyales para sa hakbang na ito:

Mga turnilyo ng makinaMga turnilyo ng makina2 piraso
1.5 V na button cell1.5 V na button cell2 piraso

Mga kailangang kasangkapan:

Set ng tumpak na distornilyadorSet ng tumpak na distornilyador
Kalipers na VernierKalipers na Vernier

Mga Materyales

15

Mga Kinakailangang Kasangkapan

7

Mga Materyales ng Nakakonektang Blueprint

CC0 Pampublikong Domain

Ang blueprint na ito ay inilabas sa ilalim ng CC0. Malaya kang kumopya, magbago, mamahagi, at gumamit nang walang pahintulot.

Suportahan ang Maker sa pamamagitan ng pagbili ng mga produkto sa kanilang Blueprint Komisyon ng Maker itinakda ng mga Vendor, o lumikha ng bagong bersyon ng Blueprint na ito at isama bilang koneksyon sa iyong Blueprint upang ibahagi ang kita.

Talakayan

(0)

Mag-login upang sumali sa talakayan

Naglo-load ng mga komento...