تعاون
فن
خوبصورتی اور تندرستی
دستکاری
ثقافت اور تاریخ
تفریح
ماحول
خوراک اور مشروبات
ریورس انجینئرنگ
سائنسز
کھیل
ٹیکنالوجی
پہننے والے آلات
Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)
Ed

تخلیق کار

Ed

2. نومبر 2026FI
13
0
0
0
0

Digital Caliper: Capacitive Scale and Slider with Two-Chip Electronics (Baxter and Buehler, Starrett, 1986)

A six-inch caliper that reads out on a display. Under the slide, a strip of etched copper bars runs along the beam. Electrodes on the slider pass a signal through the bars by capacitance, and the slider's electronics count the bars crossed and work out the position in between. Result: a digital caliper reading in inches or millimetres, repeatable to a ten-thousandth of an inch, with floating zero, peak hold and high/low limits. It runs on two 1.5 V cells at 10-50 microamps. Source: L. K. Baxter and R. J. Buehler (L. S. Starrett Co.), US Patent 4,586,260 (1986). Unknown: the metal of the beam, slide and rod, their dimensions, the processor's program, and how the chips and display are made. Ours: the etchant, photoresist and glue. Picture: Wikimedia Commons.
اعلیٰ
2 days

ہدایات

1

Etch the scale

Etch the scale pattern onto a strip of copper-clad epoxy fibreglass with photoresist and etchant. Each copper bar is 0.40 inch long, with a wider centre 0.12 inch long and two ends 0.14 inch long. Space the bars on 0.05 inch centres: the centres sit 0.004 inch apart, the ends 0.025 inch apart. Run the pattern the full length of the scale. Ours: dry film resist and ferric chloride.

اس مرحلے کے لیے مواد:

خالی چھپا ہوا سرکٹ بورڈ (تانبے کی تہہ)خالی چھپا ہوا سرکٹ بورڈ (تانبے کی تہہ)1 strip, length of the beam

درکار اوزار:

خشک فلم فوٹو ریزسٹخشک فلم فوٹو ریزسٹ
فیرک کلورائیڈ کا محلولفیرک کلورائیڈ کا محلول
کیمیائی اثر روکنے والے دستانےکیمیائی اثر روکنے والے دستانے
2

Fix the scale into the beam

The beam is a metal bar with the fixed outside and inside jaws at one end, a wide shallow channel in its face and a second channel along its back. Fix the scale permanently into the face channel, copper up. The patent allows etching before or after this step. Not given: the metal, the dimensions and how the scale is fixed. Ours: epoxy.

اس مرحلے کے لیے مواد:

کیلیپر کی بیمکیلیپر کی بیم1 with integral jaws
دو جزو والی ایپوکسیدو جزو والی ایپوکسی1 a little

درکار اوزار:

نامعلوم پیمائشنامعلوم پیمائش
3

Fit the parts to the circuit

The circuit is one folded piece: a double-sided slider board joined by a flexible hinge to a circuit board. Its bottom face has two pickup electrodes, 0.750 x 0.110 inch and 0.0625 inch apart. On each side of them is an interdigitated transmitter array: fingers 0.115 inch long on 0.025 inch spacing, opening to 0.0375 inch at the centre. On the circuit board, solder or wire-bond the two chips: an NEC uPD7503 3 V processor (768 bits RAM, 2 kB ROM) and a CMOS gate array. Then fit the LCD, the 100 kHz crystal, the integrating capacitor and the MODE and SET buttons. Not given: the processor's program. Ours: a capacitor from a kit.

اس مرحلے کے لیے مواد:

سخت و لچکدار سرکٹ بورڈسخت و لچکدار سرکٹ بورڈ1 slider board + circuit board
انٹیگریٹڈ سرکٹ (IC)انٹیگریٹڈ سرکٹ (IC)2 uPD7503 CPU, CMOS gate array
سیگمنٹ ایل سی ڈی پینلسیگمنٹ ایل سی ڈی پینل1 5 digits
کوارٹز کرسٹلکوارٹز کرسٹل1 100 kHz
کپیسیٹر کِٹکپیسیٹر کِٹ1 one integrating capacitor
دبانے کا بٹندبانے کا بٹن2 MODE, SET
ٹانکے کا تارٹانکے کا تار1 a little

درکار اوزار:

ٹانکا لگانے کی سلاخٹانکا لگانے کی سلاخ
4

Build the slide

The slide frame wraps the back and edges of the beam and carries the movable jaws. Fix it to the depth rod, which runs in the back channel of the beam; the rod's free end is the depth gauge. Put the moulded plastic housing between the frame ends. Fasten two metal wear strips under the slider board, one on each side of the scale. They ride on the beam and connect the board's copper to it. Not given: the metal and sizes.

اس مرحلے کے لیے مواد:

سلائیڈ کا فریمسلائیڈ کا فریم1 with jaws
نامعلوم دھاتنامعلوم دھات1 depth rod and two wear strips
سلائیڈ کا خولسلائیڈ کا خول1 ٹکڑا

درکار اوزار:

نامعلوم پیمائشنامعلوم پیمائش
باریک پیچ کش سیٹباریک پیچ کش سیٹ
5

Assemble and check

Fold the circuit into the housing recess, slider board facing the scale, and screw it to the frame. The electrodes must lie parallel to the scale bars at every point of travel. Put the two 1.5 V cells (the patent says 'zinc oxide') in the battery pockets of the circuit. The display shows five digits, a ten-thousandths bar graph, a minus sign and 'mm', plus PEAK, LOW, HIGH and LIMIT. Ours: check the reading against a vernier caliper.

اس مرحلے کے لیے مواد:

مشینی پیچمشینی پیچ2 ٹکڑے
1.5 وولٹ بٹن سیل1.5 وولٹ بٹن سیل2 ٹکڑے

درکار اوزار:

باریک پیچ کش سیٹباریک پیچ کش سیٹ
ورنیئر کیلیپرورنیئر کیلیپر

مواد

15

درکار اوزار

7

CC0 پبلک ڈومین

یہ بلیو پرنٹ CC0 کے تحت جاری کیا گیا ہے۔ آپ اجازت لیے بغیر اس کام کو نقل، ترمیم، تقسیم اور کسی بھی مقصد کے لیے استعمال کرنے کے لیے آزاد ہیں۔

میکر کی حمایت کریں ان کے بلیو پرنٹ کے ذریعے پروڈکٹس خرید کر جہاں وہ میکر کمیشن وینڈرز کی طرف سے مقرر، کماتے ہیں، یا اس بلیو پرنٹ کی نئی تکرار بنائیں اور آمدنی شیئر کرنے کے لیے اسے اپنے بلیو پرنٹ میں کنکشن کے طور پر شامل کریں۔

بحث

(0)

لاگ ان بحث میں شامل ہونے کے لیے

تبصرے لوڈ ہو رہے ہیں...